Severity
Moderate
ModerateActive
CPSC recall · Reported April 13, 2004
CPSC, Nikko America Announce Recall of Radio-Control Toy Trucks
A problem with the circuit board causes the toy truck to overheat, posing a fire and burn hazard.
Compiled from official public sources by the editorial team.
Verify with CPSC →
Nikko America Inc., of Plano, Texas recalled The recalled toy trucks were manufactured from April 2003 through January 2004. The truck… - a moderate-severity action.
CPSC, Nikko America Announce Recall of Radio-Control Toy Trucks was recalled by Nikko America Inc., of Plano, Texas in April 13, 2004. Reason: A problem with the circuit board causes the toy truck to overheat, posing a fire and burn hazard.. Remedy: Consumers should stop using the toy trucks and contact Nikko America for instructions on …. Verify recall #04117 with the CPSC before acting.
The recall
Nikko America Inc., of Plano, Texas issued this moderate-severity CPSC recall-A problem with the circuit board causes the toy truck to overheat, posing a fire and burn hazard..
- Moderate
- severity level
- April 13, 2004
- reported
Sourced from official CPSC enforcement records. Verify recall #04117 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #04117) was formally reported on April 13, 2004. It is classified under Moderate severity, with a current status of Active. Nikko America Inc., of Plano, Texas is listed as the recalling firm. Federal records list the affected scope as About 287,000.
The documented reason for this recall is: A problem with the circuit board causes the toy truck to overheat, posing a fire and burn hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using the toy trucks and contact Nikko America for instructions on returning the product for a free circuit board replacement. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,642 vehicles recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 287,000
Related Recalls
6
6 from same agency
Product description
The recalled toy trucks were manufactured from April 2003 through January 2004. The trucks are 1/10 scale models (approximately 18 inches in length) of the Chevy Avalanche (model 100021A), the Jeep Wrangler Rubicon (model 100022A and 100022B), the Hummer Wagon (model 100023A and 100023B) and the Ford F150 (model 100024A and 100024B). Model numbers can be found on the body of the truck, along with the vehicle make and model names.
Reason for recall
A problem with the circuit board causes the toy truck to overheat, posing a fire and burn hazard.
Remedy, what to do
Consumers should stop using the toy trucks and contact Nikko America for instructions on returning the product for a free circuit board replacement.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 04117 |
| Date reported | April 13, 2004 |
| Date initiated | April 13, 2004 |
| Recalling firm | Nikko America Inc., of Plano, Texas |
| Affected scope | About 287,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using the toy trucks and contact Nikko America for instructions on returning the product for a free circuit…
- Check the recall number (04117) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
The recalled toy trucks were manufactured from April 2003 through January 2004. The trucks are 1/10 scale models (approximately 18 inches in length) of the Chevy Avalanche (model 100021A), the Jeep Wrangler Rubicon (model 100022A and 100022B), the Hummer Wagon (model 100023A and 100023B) and the Ford F150 (model 100024A and 100024B). Model numbers can be found on the body of the truck, along with the vehicle make and model names.. Recalled by Nikko America Inc., of Plano, Texas. Units affected: About 287,000.
Why was this product recalled? ▼
A problem with the circuit board causes the toy truck to overheat, posing a fire and burn hazard.
What should consumers do? ▼
Consumers should stop using the toy trucks and contact Nikko America for instructions on returning the product for a free circuit board replacement.
Which agency issued this recall? ▼
This recall was issued by the CPSC on April 13, 2004. Severity: Moderate. Recall number: 04117.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (04117) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Yamazuki Recalls Youth All-Terrain Vehicles (ATVs) Due to Risk of Serious Injury or Death from Crash; Violate Mandatory…
Yongkang Ruihe Metal Products Co. Ltd., of China · 2026-06-25
CPSC Moderate
Joolz Recalls Aer2 Car Seat Adapters for Strollers Due to Risk of Serious Injury from Fall Hazard
· 2026-06-18
CPSC Moderate
Joolz Recalls Aer2 Car Seat Adapters for Strollers Due to Risk of Serious Injury or Death from Suffocation and Fall Haz…
CooCooBaby, of China · 2026-06-18
CPSC Moderate
Kawasaki Motors USA Recalls Model Year 2026 Teryx4 H2 and Teryx5 H2 Recreational Off-Road Vehicles Due to Impact and In…
Kawasaki Motors Manufacturing Corp., U.S.A., of Lincoln, Nebraska · 2026-06-11
CPSC Moderate
Yamaha Recalls Model Year 2021-2022 Fleet Golf Cars Due to Risk of Serious Injury or Death from a Crash Hazard
· 2026-06-11
Compare this recall with Yamazuki Recalls Youth All-Terrain Vehicles (ATVs) Due to R… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported April 13, 2004. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.