CPSC recall · Reported June 15, 2004
CPSC, Basler Electric Co. and Lutron Electronics Announce Recall of Power Supply Units
The power supply, if overloaded, can overheat, posing a fire hazard to consumers.
Basler Electric Co., of Highland, Ill. recalled These recalled 12-volt DC power supply units were sold as an accessory power supply devic….
CPSC, Basler Electric Co. and Lutron Electronics Announce Recall of Power Supply Units was recalled by Basler Electric Co., of Highland, Ill. in June 15, 2004. Reason: The power supply, if overloaded, can overheat, posing a fire hazard to consumers.. Remedy: Consumers should contact Lutron Electronics to receive a free replacement power supply un…. Verify recall #04161 with the CPSC before acting.
The recall
Basler Electric Co., of Highland, Ill. issued this CPSC recall-The power supply, if overloaded, can overheat, posing a fire hazard to consumers..
- None
- agency class
- 3K units
- affected scope
- June 15, 2004
- reported
Sourced from official CPSC enforcement records. Verify recall #04161 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Medical Devices recalls over time
Where this recall sits in its category - 41,021 medical devices recalls on record
Product description
These recalled 12-volt DC power supply units were sold as an accessory power supply device for some of Lutron Electronic's wall stations and control interfaces, including some Grafik Eye 3000 lighting control systems. These systems were professionally installed in indoor commercial and residential settings for lighting and dimmer control applications. The power supplies are black plastic with "Basler Electric" and the model number "BE29736001" imprinted on the plug side. On the opposite side is a blue and white Lutron label with the number "GRX-12VDC." Lutron's Grafik Eye 3000 lighting system is not part of the recall.
Reason for recall
The power supply, if overloaded, can overheat, posing a fire hazard to consumers.
Remedy, what to do
Consumers should contact Lutron Electronics to receive a free replacement power supply unit.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 04161 |
| Date reported | June 15, 2004 |
| Date initiated | June 15, 2004 |
| Recalling firm | Basler Electric Co., of Highland, Ill. |
| Affected scope | 3,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should contact Lutron Electronics to receive a free replacement power supply unit.
- Check the recall number (04161) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Medical Devices · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with GORE VIABIL Short Wire Biliary Endoprosthesis, Model No. VS… → · All Medical Devices recalls
Methodology · Corrections · Archive as of August 2026