NHTSA recall · Reported August 29, 2005
SUZUKI 2003-2004: ELECTRICAL SYSTEM:IGNITION:SWITCH
ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN …
Suzuki recalled ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON….
SUZUKI 2003-2004: ELECTRICAL SYSTEM:IGNITION:SWITCH was recalled by Suzuki in August 29, 2005. Reason: ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MA…. Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH TERMINAL CASE ASSEMBLY FREE OF CHARGE. THE RECA…. Verify recall #05V372000 with the NHTSA before acting.
The recall
Suzuki issued this NHTSA recall-ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MA….
- None
- agency class
- August 29, 2005
- reported
Sourced from official NHTSA enforcement records. Verify recall #05V372000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN CAUSE ARCING IN THE IGNITION SWITCH.
Reason for recall
ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN CAUSE ARCING IN THE IGNITION SWITCH.
Hazard
HEAT FROM THE ARCING CAN MELT THE INTERNAL SWITCH BASE PLATE. IF THE SCOOTER IS RIDDEN IN THIS CONDITION, THE IGNITION SWITCH MAY FAIL. IF THIS HAPPENS, THE ENGINE WILL STALL, THE LIGHTS WILL GO OUT, AND THE OPERATOR MAY BE UNABLE TO RESTART THE SCOOTER. THIS COULD RESULT IN A CRASH.
Remedy, what to do
DEALERS WILL REPLACE THE IGNITION SWITCH TERMINAL CASE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 7, 2005. OWNERS MAY CONTACT SUZUKI AT 1-800-255-2550.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 05V372000 |
| Date reported | August 29, 2005 |
| Date initiated | August 29, 2005 |
| Recalling firm | Suzuki |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
DEALERS WILL REPLACE THE IGNITION SWITCH TERMINAL CASE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 7, 2005. OWNERS M…
- Check the recall number (05V372000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026