Delta Combination Water Heaters Recalled by Triangle Tube for Carbon Monoxide Poisoning Hazard

Recall Insight

This CPSC action (record #06252) was formally reported on September 7, 2006. It is classified under Moderate severity, with a current status of Active. Triangle Tube/Phase III, of Blackwood, N.J. is listed as the recalling firm. Federal records indicate About 3,000 units are affected.

The documented reason for this recall is: The burner plate and flue hood seal on the water heaters can fail due to an improper seal causing a leak of flue gases and carbon monoxide (CO). This poses the risk of CO poisoning to consumers inside of the house. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using the recalled water heaters and contact Triangle Tube to schedule a free repair. — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 1 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 20 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.