Severity
Moderate
ModerateActive
CPSC recall · Reported February 1, 2006
CPSC, Weil-McLain Company Announce Recall of Boilers
The blower assembly is not properly sealed. Gas can leak during operation and accumulate. If an ignition source is present, a fire or explosion could occur.
Compiled from official public sources by the editorial team.
Verify with CPSC →
Weil-McLain Company, of Michigan City, Ind. recalled Weil-McClain GV water boiler Models GV-3, GV-4, GV-5 and GV-6 with a serial number/date c… - a moderate-severity action.
CPSC, Weil-McLain Company Announce Recall of Boilers was recalled by Weil-McLain Company, of Michigan City, Ind. in February 1, 2006. Reason: The blower assembly is not properly sealed. Gas can leak during operation and accumulate. If an ignition sour…. Remedy: Weil-McLain repaired all recalled boilers at no cost to consumers.. Verify recall #06527 with the CPSC before acting.
The recall
Weil-McLain Company, of Michigan City, Ind. issued this moderate-severity CPSC recall-The blower assembly is not properly sealed. Gas can leak during operation and accumulate. If an ignition sour….
- Moderate
- severity level
- 1K units
- affected scope
- February 1, 2006
- reported
Sourced from official CPSC enforcement records. Verify recall #06527 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #06527) was formally reported on February 1, 2006. It is classified under Moderate severity, with a current status of Active. Weil-McLain Company, of Michigan City, Ind. is listed as the recalling firm. Federal records list the affected scope as 1,131.
The documented reason for this recall is: The blower assembly is not properly sealed. Gas can leak during operation and accumulate. If an ignition source is present, a fire or explosion could occur. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Weil-McLain repaired all recalled boilers at no cost to consumers. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Household Products recalls over time
Where this recall sits in its category - 3,056 household products recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
1,131
Related Recalls
6
6 from same agency
Product description
Weil-McClain GV water boiler Models GV-3, GV-4, GV-5 and GV-6 with a serial number/date code range of CP5075477 to CP5221234 and built from April 1, 2005 through October 31, 2005. Serial numbers and date codes are located on the left side of the jacket, above the boiler rating label.
Reason for recall
The blower assembly is not properly sealed. Gas can leak during operation and accumulate. If an ignition source is present, a fire or explosion could occur.
Remedy, what to do
Weil-McLain repaired all recalled boilers at no cost to consumers.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 06527 |
| Date reported | February 1, 2006 |
| Date initiated | February 1, 2006 |
| Recalling firm | Weil-McLain Company, of Michigan City, Ind. |
| Affected scope | 1,131 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Weil-McLain repaired all recalled boilers at no cost to consumers.
- Check the recall number (06527) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Weil-McClain GV water boiler Models GV-3, GV-4, GV-5 and GV-6 with a serial number/date code range of CP5075477 to CP5221234 and built from April 1, 2005 through October 31, 2005. Serial numbers and date codes are located on the left side of the jacket, above the boiler rating label.. Recalled by Weil-McLain Company, of Michigan City, Ind.. Units affected: 1,131.
Why was this product recalled? ▼
The blower assembly is not properly sealed. Gas can leak during operation and accumulate. If an ignition source is present, a fire or explosion could occur.
What should consumers do? ▼
Weil-McLain repaired all recalled boilers at no cost to consumers.
Which agency issued this recall? ▼
This recall was issued by the CPSC on February 1, 2006. Severity: Moderate. Recall number: 06527.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (06527) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Cooper Lighting Recalls Metalux Optimized High Bay LED Light Fixtures Due to Fire Hazard
Cooper Lighting, LLC, of Peachtree City, Georgia · 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Roman Candles 8 Shot Fireworks Due to Risk of Serious Injury from Explosion and B…
· 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Unity 7 Shot 200 Gram Aerial Cake Fireworks Due to Risk of Serious Injury from Ex…
· 2026-07-02
CPSC Moderate
Kith Retail Recalls Children's Loungewear Sets Due to Risk of Serious Injury from Burn Hazard; Violate Mandatory Standa…
· 2026-06-25
CPSC Moderate
Southern Telecom Expands Recall of Lomi Waxing Kits Due to Risk of Serious Injury or Death from Fire and Burn Hazards; …
· 2026-06-25
Compare this recall with Cooper Lighting Recalls Metalux Optimized High Bay LED Ligh… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported February 1, 2006. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.