Severity
Moderate
ModerateActive
CPSC recall · Reported April 25, 2006
Arctic Cat Recalls Snowmobiles Posing Fire and Burn Hazard
The recalled snowmobiles fuel tank could crack and leak, allowing fuel or fuel vapors to escape, posing a fire and burn hazard.
Compiled from official public sources by the editorial team.
Verify with CPSC →
Arctic Cat Inc., of Thief River Falls, Minn. recalled The recalled fuel tanks were installed on all 2004, 2005 and 2006 Firecat and Sabercat mo… - a moderate-severity action.
Arctic Cat Recalls Snowmobiles Posing Fire and Burn Hazard was recalled by Arctic Cat Inc., of Thief River Falls, Minn. in April 25, 2006. Reason: The recalled snowmobiles fuel tank could crack and leak, allowing fuel or fuel vapors to escape, posing a fir…. Remedy: Consumers should stop using these snowmobiles immediately unless instructed otherwise. Re…. Verify recall #06547 with the CPSC before acting.
The recall
Arctic Cat Inc., of Thief River Falls, Minn. issued this moderate-severity CPSC recall-The recalled snowmobiles fuel tank could crack and leak, allowing fuel or fuel vapors to escape, posing a fir….
- Moderate
- severity level
- April 25, 2006
- reported
Sourced from official CPSC enforcement records. Verify recall #06547 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #06547) was formally reported on April 25, 2006. It is classified under Moderate severity, with a current status of Active. Arctic Cat Inc., of Thief River Falls, Minn. is listed as the recalling firm. Federal records list the affected scope as About 41,000.
The documented reason for this recall is: The recalled snowmobiles fuel tank could crack and leak, allowing fuel or fuel vapors to escape, posing a fire and burn hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using these snowmobiles immediately unless instructed otherwise. Registered owners have been notified about this recall by mail. If consumers are unsure if their snowmobile is a… - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,642 vehicles recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 41,000
Related Recalls
6
6 from same agency
Product description
The recalled fuel tanks were installed on all 2004, 2005 and 2006 Firecat and Sabercat models. The recall also includes all 2003 Firecat carbureted models. The affected models were manufactured in a variety of colors and engine sizes. However, all are included in this recall.
Reason for recall
The recalled snowmobiles fuel tank could crack and leak, allowing fuel or fuel vapors to escape, posing a fire and burn hazard.
Remedy, what to do
Consumers should stop using these snowmobiles immediately unless instructed otherwise. Registered owners have been notified about this recall by mail. If consumers are unsure if their snowmobile is affected, they should call Arctic Cat. Consumers should have the model name and model number available. The model name and model number are displayed on the registration materials you received when you purchased your snowmobile and on your operator's manual. Consumers with a recalled snowmobile should contact their local Arctic Cat snowmobile dealer to schedule a free repair.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 06547 |
| Date reported | April 25, 2006 |
| Date initiated | April 25, 2006 |
| Recalling firm | Arctic Cat Inc., of Thief River Falls, Minn. |
| Affected scope | About 41,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using these snowmobiles immediately unless instructed otherwise. Registered owners have been notified about…
- Check the recall number (06547) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
The recalled fuel tanks were installed on all 2004, 2005 and 2006 Firecat and Sabercat models. The recall also includes all 2003 Firecat carbureted models. The affected models were manufactured in a variety of colors and engine sizes. However, all are included in this recall.. Recalled by Arctic Cat Inc., of Thief River Falls, Minn.. Units affected: About 41,000.
Why was this product recalled? ▼
The recalled snowmobiles fuel tank could crack and leak, allowing fuel or fuel vapors to escape, posing a fire and burn hazard.
What should consumers do? ▼
Consumers should stop using these snowmobiles immediately unless instructed otherwise. Registered owners have been notified about this recall by mail. If consumers are unsure if their snowmobile is affected, they should call Arctic Cat. Consumers should have the model name and model number available. The model name and model number are displayed on the registration materials you received when you purchased your snowmobile and on your operator's manual. Consumers with a recalled snowmobile should contact their local Arctic Cat snowmobile dealer to schedule a free repair.
Which agency issued this recall? ▼
This recall was issued by the CPSC on April 25, 2006. Severity: Moderate. Recall number: 06547.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (06547) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Yamazuki Recalls Youth All-Terrain Vehicles (ATVs) Due to Risk of Serious Injury or Death from Crash; Violate Mandatory…
Yongkang Ruihe Metal Products Co. Ltd., of China · 2026-06-25
CPSC Moderate
Joolz Recalls Aer2 Car Seat Adapters for Strollers Due to Risk of Serious Injury from Fall Hazard
· 2026-06-18
CPSC Moderate
Joolz Recalls Aer2 Car Seat Adapters for Strollers Due to Risk of Serious Injury or Death from Suffocation and Fall Haz…
CooCooBaby, of China · 2026-06-18
CPSC Moderate
Kawasaki Motors USA Recalls Model Year 2026 Teryx4 H2 and Teryx5 H2 Recreational Off-Road Vehicles Due to Impact and In…
Kawasaki Motors Manufacturing Corp., U.S.A., of Lincoln, Nebraska · 2026-06-11
CPSC Moderate
Yamaha Recalls Model Year 2021-2022 Fleet Golf Cars Due to Risk of Serious Injury or Death from a Crash Hazard
· 2026-06-11
Compare this recall with Yamazuki Recalls Youth All-Terrain Vehicles (ATVs) Due to R… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported April 25, 2006. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.