CPSC recall · Reported July 27, 2006
Generac Power Systems Inc. Recalls Engines to Replace Fuel Tanks Due to Risk of Fire
The plastic fuel tanks can leak. If an ignition source is present, a fire or explosion can occur.
Generac Power Systems Inc., of Waukesha, Wis. recalled The following industrial power equipment products, manufactured by the original equipment….
Generac Power Systems Inc. Recalls Engines to Replace Fuel Tanks Due to Risk of Fire was recalled by Generac Power Systems Inc., of Waukesha, Wis. in July 27, 2006. Reason: The plastic fuel tanks can leak. If an ignition source is present, a fire or explosion can occur.. Remedy: Consumers who purchased power equipment with the recalled engine should stop using it imm…. Verify recall #06569 with the CPSC before acting.
The recall
Generac Power Systems Inc., of Waukesha, Wis. issued this CPSC recall-The plastic fuel tanks can leak. If an ignition source is present, a fire or explosion can occur..
- None
- agency class
- July 27, 2006
- reported
Sourced from official CPSC enforcement records. Verify recall #06569 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
The following industrial power equipment products, manufactured by the original equipment manufacturers (OEMs) listed below, are included in this recall: Power Equipment Type OEM/Equipment Seller Pressure Washer Cleaning Systems Specialists, Inc. Phone: (619) 448-8111 Air Compressors Ingersoll-Rand Phone: (800) 820-0308 Pressure Washers Silver Eagle Phone: (936) 264-2215 Saw Mill Wood Mizer Phone: (317) 808-0717 The recalled Generac GTH410 and GTH220 engines were manufactured from July 2001 to July 2005. GTH410 Engines model numbers with defective fuel tanks are: 0041930EHF; 0043290EHF; 0043291; 0045050EHF; 0045281; 0045283; 0046100EHF; 0046150EHF; 0046910EHF; 0046911. GTH220 Engines model numbers with defective fuel tanks are: 0040990EHC; 0043930EHC; 0045300EHC; 0046090EHC; 0046370EHC; 0046380EHC; 0046390EHC; 0046820EHC; 0047640EHC; 0048820; 0050650; 0051170. The engine model number is located on the side of the motor and contained on a small sticker above the Generac nameplate. The top number on the small sticker is the model number (e.g., 220 or 410). The larger Generac nameplate contains the Engine Identification Number and Serial Number.
Reason for recall
The plastic fuel tanks can leak. If an ignition source is present, a fire or explosion can occur.
Remedy, what to do
Consumers who purchased power equipment with the recalled engine should stop using it immediately and contact the equipment manufacturer to schedule a free tank replacement.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 06569 |
| Date reported | July 27, 2006 |
| Date initiated | July 27, 2006 |
| Recalling firm | Generac Power Systems Inc., of Waukesha, Wis. |
| Affected scope | About 700 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers who purchased power equipment with the recalled engine should stop using it immediately and contact the equipment manuf…
- Check the recall number (06569) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026