CPSC recall · Reported October 19, 2006
Kawasaki Motors Corp., USA Recalls ATV for Loss of Steering Control Hazard
The nuts securing the tie-rod ends to the steering shaft may not have been tightened sufficiently during assembly. If the nuts loosen during operation, the operator could lose ste…
Kawasaki Motors Corp., U.S.A., of Irvine, Calif. recalled The recall involves 2007 model year Kawasaki KLF250A7F ATVs. These are 4-wheel ATVs sold ….
Kawasaki Motors Corp., USA Recalls ATV for Loss of Steering Control Hazard was recalled by Kawasaki Motors Corp., U.S.A., of Irvine, Calif. in October 19, 2006. Reason: The nuts securing the tie-rod ends to the steering shaft may not have been tightened sufficiently during asse…. Remedy: Consumers should stop using the ATV immediately and contact their local Kawasaki dealer t…. Verify recall #07504 with the CPSC before acting.
The recall
Kawasaki Motors Corp., U.S.A., of Irvine, Calif. issued this CPSC recall-The nuts securing the tie-rod ends to the steering shaft may not have been tightened sufficiently during asse….
- None
- agency class
- 291 units
- affected scope
- October 19, 2006
- reported
Sourced from official CPSC enforcement records. Verify recall #07504 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
The recall involves 2007 model year Kawasaki KLF250A7F ATVs. These are 4-wheel ATVs sold under the brand name Kawasaki Bayou 250. They are available in red, green, or white, and the words "Kawasaki" and "Bayou" are on the sides, and "250" on the rear fender.
Reason for recall
The nuts securing the tie-rod ends to the steering shaft may not have been tightened sufficiently during assembly. If the nuts loosen during operation, the operator could lose steering control, posing a risk of crashing.
Remedy, what to do
Consumers should stop using the ATV immediately and contact their local Kawasaki dealer to schedule a free repair. The correction will consist of tightening the tie-rod end mounting nuts to the proper torque. Kawasaki dealers will correct this problem at no charge.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 07504 |
| Date reported | October 19, 2006 |
| Date initiated | October 19, 2006 |
| Recalling firm | Kawasaki Motors Corp., U.S.A., of Irvine, Calif. |
| Affected scope | 291 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using the ATV immediately and contact their local Kawasaki dealer to schedule a free repair. The correction…
- Check the recall number (07504) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026