Severity
Moderate
ModerateActive
CPSC recall · Reported March 20, 2007
American Suzuki Motor Corp. Recalls All-Terrain Vehicles
The bushing pivot mount boss on the left and right suspension arm may not have been welded completely and could break off during riding. If this occurs, the rider could lose contr…
Compiled from official public sources by the editorial team.
Verify with CPSC →
American Suzuki Motor Corp., of Brea, Calif. recalled The recalled product is a Suzuki 2007 model year QuadSport Z90 ATV with model number LT-Z… - a moderate-severity action.
American Suzuki Motor Corp. Recalls All-Terrain Vehicles was recalled by American Suzuki Motor Corp., of Brea, Calif. in March 20, 2007. Reason: The bushing pivot mount boss on the left and right suspension arm may not have been welded completely and cou…. Remedy: Consumers should stop using these vehicles immediately and contact the local Suzuki ATV d…. Verify recall #07537 with the CPSC before acting.
The recall
American Suzuki Motor Corp., of Brea, Calif. issued this moderate-severity CPSC recall-The bushing pivot mount boss on the left and right suspension arm may not have been welded completely and cou….
- Moderate
- severity level
- March 20, 2007
- reported
Sourced from official CPSC enforcement records. Verify recall #07537 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #07537) was formally reported on March 20, 2007. It is classified under Moderate severity, with a current status of Active. American Suzuki Motor Corp., of Brea, Calif. is listed as the recalling firm. Federal records list the affected scope as About 3,500.
The documented reason for this recall is: The bushing pivot mount boss on the left and right suspension arm may not have been welded completely and could break off during riding. If this occurs, the rider could lose control of the ATV and crash, posing risk of … Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using these vehicles immediately and contact the local Suzuki ATV dealer to schedule an appointment for a free repair. Consumers with the recalled ATVs are being sent direct not… - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,642 vehicles recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 3,500
Related Recalls
6
6 from same agency
Product description
The recalled product is a Suzuki 2007 model year QuadSport Z90 ATV with model number LT-Z90K7. The model number is located on the lower right side of the ATV frame. The vehicle identification number (VIN) is located on the left rear side of the ATV frame. Refer to the VIN list on www.suzukicycles.com These ATVs were sold in yellow and white colors. Writing on the ATVs includes: "QuadSport," printed in silver or white letters, "Z90," printed in red/black letters and "Suzuki," printed in black letters.
Reason for recall
The bushing pivot mount boss on the left and right suspension arm may not have been welded completely and could break off during riding. If this occurs, the rider could lose control of the ATV and crash, posing risk of serious injury or death.
Remedy, what to do
Consumers should stop using these vehicles immediately and contact the local Suzuki ATV dealer to schedule an appointment for a free repair. Consumers with the recalled ATVs are being sent direct notices from Suzuki.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 07537 |
| Date reported | March 20, 2007 |
| Date initiated | March 20, 2007 |
| Recalling firm | American Suzuki Motor Corp., of Brea, Calif. |
| Affected scope | About 3,500 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using these vehicles immediately and contact the local Suzuki ATV dealer to schedule an appointment for a f…
- Check the recall number (07537) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
The recalled product is a Suzuki 2007 model year QuadSport Z90 ATV with model number LT-Z90K7. The model number is located on the lower right side of the ATV frame. The vehicle identification number (VIN) is located on the left rear side of the ATV frame. Refer to the VIN list on www.suzukicycles.com These ATVs were sold in yellow and white colors. Writing on the ATVs includes: "QuadSport," printed in silver or white letters, "Z90," printed in red/black letters and "Suzuki," printed in black letters.. Recalled by American Suzuki Motor Corp., of Brea, Calif.. Units affected: About 3,500.
Why was this product recalled? ▼
The bushing pivot mount boss on the left and right suspension arm may not have been welded completely and could break off during riding. If this occurs, the rider could lose control of the ATV and crash, posing risk of serious injury or death.
What should consumers do? ▼
Consumers should stop using these vehicles immediately and contact the local Suzuki ATV dealer to schedule an appointment for a free repair. Consumers with the recalled ATVs are being sent direct notices from Suzuki.
Which agency issued this recall? ▼
This recall was issued by the CPSC on March 20, 2007. Severity: Moderate. Recall number: 07537.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (07537) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Yamazuki Recalls Youth All-Terrain Vehicles (ATVs) Due to Risk of Serious Injury or Death from Crash; Violate Mandatory…
Yongkang Ruihe Metal Products Co. Ltd., of China · 2026-06-25
CPSC Moderate
Joolz Recalls Aer2 Car Seat Adapters for Strollers Due to Risk of Serious Injury from Fall Hazard
· 2026-06-18
CPSC Moderate
Joolz Recalls Aer2 Car Seat Adapters for Strollers Due to Risk of Serious Injury or Death from Suffocation and Fall Haz…
CooCooBaby, of China · 2026-06-18
CPSC Moderate
Kawasaki Motors USA Recalls Model Year 2026 Teryx4 H2 and Teryx5 H2 Recreational Off-Road Vehicles Due to Impact and In…
Kawasaki Motors Manufacturing Corp., U.S.A., of Lincoln, Nebraska · 2026-06-11
CPSC Moderate
Yamaha Recalls Model Year 2021-2022 Fleet Golf Cars Due to Risk of Serious Injury or Death from a Crash Hazard
· 2026-06-11
Compare this recall with Yamazuki Recalls Youth All-Terrain Vehicles (ATVs) Due to R… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported March 20, 2007. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.