Severity
Moderate
ModerateActive
CPSC recall · Reported April 22, 2008
Nashbar Direct Inc. Recalls Bicycle Resistance Trainers Due to Puncture Hazard
The springs in the resistance trainers can unhook and become a projectile, posing a puncture hazard to users or bystanders.
Compiled from official public sources by the editorial team.
Verify with CPSC →
The CPSC recalled The recalled trainers are folding stands that lift and apply resistance to the rear wheel… - a moderate-severity action.
Nashbar Direct Inc. Recalls Bicycle Resistance Trainers Due to Puncture Hazard was recalled and listed by the CPSC in April 22, 2008. Reason: The springs in the resistance trainers can unhook and become a projectile, posing a puncture hazard to users …. Remedy: Consumers should immediately stop using these bicycle trainers and contact Nashbar to rec…. Verify recall #08559 with the CPSC before acting.
The recall
issued this moderate-severity CPSC recall-The springs in the resistance trainers can unhook and become a projectile, posing a puncture hazard to users ….
- Moderate
- severity level
- April 22, 2008
- reported
Sourced from official CPSC enforcement records. Verify recall #08559 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #08559) was formally reported on April 22, 2008. It is classified under Moderate severity, with a current status of Active. The recalling firm is not specified in the federal record. Federal records list the affected scope as About 200.
The documented reason for this recall is: The springs in the resistance trainers can unhook and become a projectile, posing a puncture hazard to users or bystanders. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using these bicycle trainers and contact Nashbar to receive a free repair or refund. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Outdoor & Sports recalls over time
Where this recall sits in its category - 510 outdoor & sports recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 200
Related Recalls
6
6 from same agency
Product description
The recalled trainers are folding stands that lift and apply resistance to the rear wheel of a standard bike, converting the bike into a stationary trainer. The recall includes Travel Trac Gravity Inertial Trainers (catalog # NB-TTMIF) with a looping black base with two red support arms. "Travel Trac" is printed in white on the right support arm and "Millennium" is printed in white on the left arm. "Inertial" is printed on the top of the right arm in black with a white border. The resistance unit has a rounded black plastic cover with a soft red elastomer roller. The item number is also printed on the bottom of the last page of the owner's manual.
Reason for recall
The springs in the resistance trainers can unhook and become a projectile, posing a puncture hazard to users or bystanders.
Remedy, what to do
Consumers should immediately stop using these bicycle trainers and contact Nashbar to receive a free repair or refund.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 08559 |
| Date reported | April 22, 2008 |
| Date initiated | April 22, 2008 |
| Recalling firm | Not disclosed |
| Affected scope | About 200 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using these bicycle trainers and contact Nashbar to receive a free repair or refund.
- Check the recall number (08559) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
The recalled trainers are folding stands that lift and apply resistance to the rear wheel of a standard bike, converting the bike into a stationary trainer. The recall includes Travel Trac Gravity Inertial Trainers (catalog # NB-TTMIF) with a looping black base with two red support arms. "Travel Trac" is printed in white on the right support arm and "Millennium" is printed in white on the left arm. "Inertial" is printed on the top of the right arm in black with a white border. The resistance unit has a rounded black plastic cover with a soft red elastomer roller. The item number is also printed on the bottom of the last page of the owner's manual.. Units affected: About 200.
Why was this product recalled? ▼
The springs in the resistance trainers can unhook and become a projectile, posing a puncture hazard to users or bystanders.
What should consumers do? ▼
Consumers should immediately stop using these bicycle trainers and contact Nashbar to receive a free repair or refund.
Which agency issued this recall? ▼
This recall was issued by the CPSC on April 22, 2008. Severity: Moderate. Recall number: 08559.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (08559) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Topyond Pool Drain Ports with Covers Recalled Due to Risk of Serious Injury or Death from Entrapment and Drowning Hazar…
Changsha Jiali Duo Technology Co., Ltd., dba Topyond, of China · 2026-07-02
CPSC Moderate
Spa Drain Covers Recalled Due to Risk of Serious Injury or Death from Entrapment and Drowning Hazards; Violate Virginia…
Shenzhen Fuxiangyue Technology Co., Ltd., dba Arrogantf, of China · 2026-06-18
CPSC Moderate
Houoto 642-2150V Pool Drain Covers Recalled Due to Risk of Serious Injury or Death from Entrapment and Drowning Hazards…
Foshan Nanhai District Haichen Tengfei Hardware Factory, of China · 2026-06-11
CPSC Moderate
Joyin Recalls Sloosh Dive Sticks Due to Risk of Serious Injury from Impalement; Violate Federal Dive Sticks Ban
· 2026-06-11
CPSC Moderate
Bicycle Helmets Recalled Due to Risk of Serious Injury or Death from Head Injury; Violates Mandatory Standard for Bicyc…
Dongguanshizhouhedianzishangwuyouxiangongsi (Dongguan Zhouhe E-commerce Co., Ltd.) dba Gudook Outdoor Sports, of China · 2026-06-04
Compare this recall with Topyond Pool Drain Ports with Covers Recalled Due to Risk o… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported April 22, 2008. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.