NHTSA recall · Reported March 11, 2008
BMW 2007: SUSPENSION:REAR
BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEAR…
Bmw recalled BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES M….
BMW 2007: SUSPENSION:REAR was recalled by Bmw in March 11, 2008. Reason: BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRON…. Remedy: DEALERS WILL CHECK AND INSTALL A CORRECT CIRCLIP, ALONG WITH A NEW SPACER BUSHING, WHEEL …. Verify recall #08V111000 with the NHTSA before acting.
The recall
Bmw issued this NHTSA recall-BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRON….
- None
- agency class
- March 11, 2008
- reported
Sourced from official NHTSA enforcement records. Verify recall #08V111000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEARING GUIDE. THIS CIRCLIP CAN RUB AGAINST A SPACER BUSHING, CREATING METAL SHAVINGS WHICH MAY ENTER THE WHEEL BEARING, CAUSING IT TO FAIL AND THE ANTILOCK BRAKE SYSTEM (ABS) MAY MALFUNCTION. THIS WOULD BE INDICATED BY ILLUMINATION OF THE ABS WARNING LAMP.
Reason for recall
BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEARING GUIDE. THIS CIRCLIP CAN RUB AGAINST A SPACER BUSHING, CREATING METAL SHAVINGS WHICH MAY ENTER THE WHEEL BEARING, CAUSING IT TO FAIL AND THE ANTILOCK BRAKE SYSTEM (ABS) MAY MALFUNCTION. THIS WOULD BE INDICATED BY ILLUMINATION OF THE ABS WARNING LAMP.
Hazard
IF THIS HAPPENED, THE BRAKES WOULD REMAIN FULLY AVAILABLE TO SLOW AND STOP THE MOTORCYCLE. DEPENDING ON TRAFFIC AND ROAD CONDITIONS AS WELL AS A RIDER'S REACTIONS, COULD INCREASE THE RISK OF A CRASH.
Remedy, what to do
DEALERS WILL CHECK AND INSTALL A CORRECT CIRCLIP, ALONG WITH A NEW SPACER BUSHING, WHEEL BEARINGS, AND SHAFT SEALING RINGS FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 08V111000 |
| Date reported | March 11, 2008 |
| Date initiated | March 11, 2008 |
| Recalling firm | Bmw |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
DEALERS WILL CHECK AND INSTALL A CORRECT CIRCLIP, ALONG WITH A NEW SPACER BUSHING, WHEEL BEARINGS, AND SHAFT SEALING RINGS FREE O…
- Check the recall number (08V111000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026