NHTSA recall · Reported July 23, 2008
MACK 2009: EXTERIOR LIGHTING:HEADLIGHTS
MACK IS RECALLING CERTAIN MY 2009 TRUCKS EQUIPPED WITH HELLA HEADLAMPS FOR FAILING TO COMPLY WITH THE PHOTOMETRIC OUTPUT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. …
Mack recalled MACK IS RECALLING CERTAIN MY 2009 TRUCKS EQUIPPED WITH HELLA HEADLAMPS FOR FAILING TO COM….
MACK 2009: EXTERIOR LIGHTING:HEADLIGHTS was recalled by Mack in July 23, 2008. Reason: MACK IS RECALLING CERTAIN MY 2009 TRUCKS EQUIPPED WITH HELLA HEADLAMPS FOR FAILING TO COMPLY WITH THE PHOTOME…. Remedy: DEALERS WILL INSPECT THE HEADLAMPS FOR THE SUSPECT DATE CODES AND REPLACE AS REQUIRED FRE…. Verify recall #08V331000 with the NHTSA before acting.
The recall
Mack issued this NHTSA recall-MACK IS RECALLING CERTAIN MY 2009 TRUCKS EQUIPPED WITH HELLA HEADLAMPS FOR FAILING TO COMPLY WITH THE PHOTOME….
- None
- agency class
- July 23, 2008
- reported
Sourced from official NHTSA enforcement records. Verify recall #08V331000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
MACK IS RECALLING CERTAIN MY 2009 TRUCKS EQUIPPED WITH HELLA HEADLAMPS FOR FAILING TO COMPLY WITH THE PHOTOMETRIC OUTPUT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEADLAMP'S BULB SHIELD MAY NOT HAVE BEEN COMPLETELY SEATED INTO THE HEADLAMP'S REFLECTOR.
Reason for recall
MACK IS RECALLING CERTAIN MY 2009 TRUCKS EQUIPPED WITH HELLA HEADLAMPS FOR FAILING TO COMPLY WITH THE PHOTOMETRIC OUTPUT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEADLAMP'S BULB SHIELD MAY NOT HAVE BEEN COMPLETELY SEATED INTO THE HEADLAMP'S REFLECTOR.
Hazard
THIS STANDARD SPECIFIES REQUIREMENTS FOR REQUIRED ORIGINAL AND REPLACEMENT LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT AND THEIR INSTALLATION. THE PURPOSE IS TO REDUCE TRAFFIC CRASHES, DEATHS AND INJURIES RESULTING FROM CRASHES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY, AND ENHANCING THE CONSPICUITY OF MOTOR VEHICLES ON THE PUBLIC ROADS SO THAT THEIR PRESENCE IS PERCEIVED AND THEIR SIGNALS UNDERSTOOD, BOTH IN DAYLIGHT AND IN DARKNESS OR OTHER CONDITIONS OF REDUCED VISIBILITY.
Remedy, what to do
DEALERS WILL INSPECT THE HEADLAMPS FOR THE SUSPECT DATE CODES AND REPLACE AS REQUIRED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 8, 2008. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 08V331000 |
| Date reported | July 23, 2008 |
| Date initiated | July 23, 2008 |
| Recalling firm | Mack |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
DEALERS WILL INSPECT THE HEADLAMPS FOR THE SUSPECT DATE CODES AND REPLACE AS REQUIRED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEM…
- Check the recall number (08V331000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026