Gas Cylinders Recalled by Worthington Cylinders Wisconsin Due to Fire Hazard

Recall Insight

This CPSC action (record #12117) was formally reported on February 23, 2012. It is classified under Moderate severity, with a current status of Active. Worthington Cylinders Wisconsin, LLC, of Chilton, Wis. is listed as the recalling firm. Federal records indicate 29,026,000 units in the U.S.; 1,371,100 units in Canada units are affected, placing this recall in the million-unit bracket that typically triggers nationwide consumer alerts and retailer sweeps.

The documented reason for this recall is: The seal on the cylinders can leak after torches or other fuel consuming equipment are disconnected from them, posing a fire hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Unused cylinders: If the cylinder has never been connected to a torch or other device, do not use cylinder. Return cylinder to store where it was purchased for exchange or full refund. Partially-used… — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 6 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 14 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.