Severity
Moderate
ModerateActive
CPSC recall · Reported June 7, 2012
Nautilus Recalls Bowflex Dumbbells Due to Injury Hazard
The weight selector dial on the units can fail, causing weight plates to fall when the dumbbell is lifted from its cradle, posing an injury hazard.
Compiled from official public sources by the editorial team.
Verify with CPSC →
Nautilus Inc. of Vancouver, Wash. recalled These black steel dumbbells are sold in pairs and can have a weight capacity of 10 to 90 … - a moderate-severity action.
Nautilus Recalls Bowflex Dumbbells Due to Injury Hazard was recalled by Nautilus Inc. of Vancouver, Wash. in June 7, 2012. Reason: The weight selector dial on the units can fail, causing weight plates to fall when the dumbbell is lifted fro…. Remedy: Consumers should stop using the recalled dumbbells immediately and contact Nautilus for a…. Verify recall #12194 with the CPSC before acting.
The recall
Nautilus Inc. of Vancouver, Wash. issued this moderate-severity CPSC recall-The weight selector dial on the units can fail, causing weight plates to fall when the dumbbell is lifted fro….
- Moderate
- severity level
- June 7, 2012
- reported
Sourced from official CPSC enforcement records. Verify recall #12194 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #12194) was formally reported on June 7, 2012. It is classified under Moderate severity, with a current status of Active. Nautilus Inc. of Vancouver, Wash. is listed as the recalling firm. Federal records list the affected scope as About 17,000.
The documented reason for this recall is: The weight selector dial on the units can fail, causing weight plates to fall when the dumbbell is lifted from its cradle, posing an injury hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using the recalled dumbbells immediately and contact Nautilus for a free repair kit. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Household Products recalls over time
Where this recall sits in its category - 3,056 household products recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 17,000
Related Recalls
6
6 from same agency
Product description
These black steel dumbbells are sold in pairs and can have a weight capacity of 10 to 90 pounds. The word 'BOWFLEX' is written in grey along the top of each handle. A selector dial on each end of the cradle lists weights in red, starting at 10 and increasing in increments of five. The red Bowflex logo is at the center of the dial. This recall involves units with a date-of-manufacture code in the serial number in the range of 1111 through 1136. The date code is the four-digit code following the letters "MAG" in the serial number. The serial number is on a white label on the bottom of the cradle. Lift the dumbbell from the cradle with all weights attached before turning over the base. Dumbbells with a black dot on the inside portion of the weight selector dial are not affected by this recall.
Reason for recall
The weight selector dial on the units can fail, causing weight plates to fall when the dumbbell is lifted from its cradle, posing an injury hazard.
Remedy, what to do
Consumers should stop using the recalled dumbbells immediately and contact Nautilus for a free repair kit.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 12194 |
| Date reported | June 7, 2012 |
| Date initiated | June 7, 2012 |
| Recalling firm | Nautilus Inc. of Vancouver, Wash. |
| Affected scope | About 17,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using the recalled dumbbells immediately and contact Nautilus for a free repair kit.
- Check the recall number (12194) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
These black steel dumbbells are sold in pairs and can have a weight capacity of 10 to 90 pounds. The word 'BOWFLEX' is written in grey along the top of each handle. A selector dial on each end of the cradle lists weights in red, starting at 10 and increasing in increments of five. The red Bowflex logo is at the center of the dial. This recall involves units with a date-of-manufacture code in the serial number in the range of 1111 through 1136. The date code is the four-digit code following the letters "MAG" in the serial number. The serial number is on a white label on the bottom of the cradle. Lift the dumbbell from the cradle with all weights attached before turning over the base. Dumbbells with a black dot on the inside portion of the weight selector dial are not affected by this recall.. Recalled by Nautilus Inc. of Vancouver, Wash.. Units affected: About 17,000.
Why was this product recalled? ▼
The weight selector dial on the units can fail, causing weight plates to fall when the dumbbell is lifted from its cradle, posing an injury hazard.
What should consumers do? ▼
Consumers should stop using the recalled dumbbells immediately and contact Nautilus for a free repair kit.
Which agency issued this recall? ▼
This recall was issued by the CPSC on June 7, 2012. Severity: Moderate. Recall number: 12194.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (12194) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Cooper Lighting Recalls Metalux Optimized High Bay LED Light Fixtures Due to Fire Hazard
Cooper Lighting, LLC, of Peachtree City, Georgia · 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Roman Candles 8 Shot Fireworks Due to Risk of Serious Injury from Explosion and B…
· 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Unity 7 Shot 200 Gram Aerial Cake Fireworks Due to Risk of Serious Injury from Ex…
· 2026-07-02
CPSC Moderate
Kith Retail Recalls Children's Loungewear Sets Due to Risk of Serious Injury from Burn Hazard; Violate Mandatory Standa…
· 2026-06-25
CPSC Moderate
Southern Telecom Expands Recall of Lomi Waxing Kits Due to Risk of Serious Injury or Death from Fire and Burn Hazards; …
· 2026-06-25
Compare this recall with Cooper Lighting Recalls Metalux Optimized High Bay LED Ligh… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported June 7, 2012. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.