Severity
Moderate
ModerateActive
CPSC recall · Reported November 16, 2011
Columbia Sportswear Recalls Batteries Sold With Jackets Due To Fire Hazard
The batteries have a cell defect which can cause overheating, posing a fire hazard.
Compiled from official public sources by the editorial team.
Verify with CPSC →
The CPSC recalled This recall involves battery packs that power heating systems in jackets. Two battery pac… - a moderate-severity action.
Columbia Sportswear Recalls Batteries Sold With Jackets Due To Fire Hazard was recalled and listed by the CPSC in November 16, 2011. Reason: The batteries have a cell defect which can cause overheating, posing a fire hazard.. Remedy: Consumers should immediately remove the battery pack from the jacket and contact the firm…. Verify recall #12705 with the CPSC before acting.
The recall
issued this moderate-severity CPSC recall-The batteries have a cell defect which can cause overheating, posing a fire hazard..
- Moderate
- severity level
- November 16, 2011
- reported
Sourced from official CPSC enforcement records. Verify recall #12705 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #12705) was formally reported on November 16, 2011. It is classified under Moderate severity, with a current status of Active. The recalling firm is not specified in the federal record. Federal records list the affected scope as About 220 (two battery packs sold with each jacket totaling 440 batteries).
The documented reason for this recall is: The batteries have a cell defect which can cause overheating, posing a fire hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately remove the battery pack from the jacket and contact the firm for instructions to return both battery packs to Columbia for free replacements. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Electronics recalls over time
Where this recall sits in its category - 609 electronics recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 220 (two battery packs sold with each jacket totaling 440 batteries)
Related Recalls
6
6 from same agency
Product description
This recall involves battery packs that power heating systems in jackets. Two battery packs were included with the following Omni-Heat™ Electric jacket styles: Omni-Heat™ Electric Wader Widgeon, Omni-Heat™ Electric Big Game and Omni-Heat™ Gale Warning Interchange. The black battery packs are 3.25 inches long by 2.3 inches wide by 0.7 inches deep and marked with "Columbia" on the top and "OMNI-HEAT™" on the bottom of the pack. "Part: 054978-001" is printed on the side label.
Reason for recall
The batteries have a cell defect which can cause overheating, posing a fire hazard.
Remedy, what to do
Consumers should immediately remove the battery pack from the jacket and contact the firm for instructions to return both battery packs to Columbia for free replacements.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 12705 |
| Date reported | November 16, 2011 |
| Date initiated | November 16, 2011 |
| Recalling firm | Not disclosed |
| Affected scope | About 220 (two battery packs sold with each jacket totaling 440 batteries) |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately remove the battery pack from the jacket and contact the firm for instructions to return both battery…
- Check the recall number (12705) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
This recall involves battery packs that power heating systems in jackets. Two battery packs were included with the following Omni-Heat™ Electric jacket styles: Omni-Heat™ Electric Wader Widgeon, Omni-Heat™ Electric Big Game and Omni-Heat™ Gale Warning Interchange. The black battery packs are 3.25 inches long by 2.3 inches wide by 0.7 inches deep and marked with "Columbia" on the top and "OMNI-HEAT™" on the bottom of the pack. "Part: 054978-001" is printed on the side label.. Units affected: About 220 (two battery packs sold with each jacket totaling 440 batteries).
Why was this product recalled? ▼
The batteries have a cell defect which can cause overheating, posing a fire hazard.
What should consumers do? ▼
Consumers should immediately remove the battery pack from the jacket and contact the firm for instructions to return both battery packs to Columbia for free replacements.
Which agency issued this recall? ▼
This recall was issued by the CPSC on November 16, 2011. Severity: Moderate. Recall number: 12705.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (12705) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Projecting LED Finger Light Toys Recalled Due to Risk of Serious Injury Death from Battery Ingestion; Violate Mandatory…
Shenzhen Bopu Product Design Co., Ltd., dba POPOOO, of China · 2026-07-02
CPSC Moderate
Combination Smoke and Carbon Monoxide (CO) Detectors Recalled Due to Risk of Serious Injury or Death from Failure to Al…
· 2026-06-25
CPSC Moderate
Raychy Children's Light Sneakers Recalled Due to Risk of Serious Injury or Death from Battery Ingestion; Violate Mandat…
· 2026-06-25
CPSC Moderate
Super Off-Road Solar Power Banks Recalled Due to Overheating; Imported by Spector & Co.
· 2026-06-25
CPSC Moderate
School Specialty Recalls Tip Restraint Kits Included in Childcraft Furniture Due to Risk of Serious Injury or Death fro…
School Specialty, LLC, of Greenville, Wisconsin · 2026-06-11
Compare this recall with Projecting LED Finger Light Toys Recalled Due to Risk of Se… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported November 16, 2011. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.