Severity
Moderate
ModerateActive
CPSC recall · Reported September 17, 2015
Zak Designs Recalls Water Bottles Due to Choking Hazard; Sold Exclusively at Target Stores
The inner plastic straw in the flip-top portion of the twist-off cap can break, posing a choking hazard.
Zak Designs Inc., of Airway Heights, Wash. recalled The recall involves Zak Designs 26-ounce plastic water bottles. The 10-inch-tall water bo… - a moderate-severity action.
Zak Designs Recalls Water Bottles Due to Choking Hazard; Sold Exclusively at Target Stores was recalled by Zak Designs Inc., of Airway Heights, Wash. in September 17, 2015. Reason: The inner plastic straw in the flip-top portion of the twist-off cap can break, posing a choking hazard.. Remedy: Consumers should immediately stop using the recalled water bottles and contact Zak Design…. Verify recall #15247 with the CPSC before acting.
The recall
Zak Designs Inc., of Airway Heights, Wash. issued this moderate-severity CPSC recall-The inner plastic straw in the flip-top portion of the twist-off cap can break, posing a choking hazard..
- Moderate
- severity level
- September 17, 2015
- reported
Sourced from official CPSC enforcement records. Verify recall #15247 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #15247) was formally reported on September 17, 2015. It is classified under Moderate severity, with a current status of Active. Zak Designs Inc., of Airway Heights, Wash. is listed as the recalling firm. Federal records list the affected scope as About 178,000.
The documented reason for this recall is: The inner plastic straw in the flip-top portion of the twist-off cap can break, posing a choking hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using the recalled water bottles and contact Zak Designs for instructions on receiving a free replacement cap with straw. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Household Products recalls over time
Where this recall sits in its category - 3,056 household products recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 178,000
Related Recalls
6
6 from same agency
Product description
The recall involves Zak Designs 26-ounce plastic water bottles. The 10-inch-tall water bottles have a flip-top spout on a twist-off cap with colored inner plastic straws in clear, blue, gray, green, light purple or red. The water bottles were sold exclusively at Target stores in a "Back-to-College" promotion. The water bottles have popular characters on the front and come in a variety of colors including clear, gray, navy blue, pink, teal blue, gray with colored caps in red, blue pink and yellow. Characters include Captain America, a Batman design, Minions, My Little Pony, Spiderman, Star Wars aircraft, a Superman logo, Teenage Mutant Ninja Turtles, Thor and Wonder Woman. Mold number "14158" and "Zak Designs®" are embossed on the bottom of the bottles in the recall. Bottles with a black inner straw and black twist-off cap are not included in the recall.
Reason for recall
The inner plastic straw in the flip-top portion of the twist-off cap can break, posing a choking hazard.
Remedy, what to do
Consumers should immediately stop using the recalled water bottles and contact Zak Designs for instructions on receiving a free replacement cap with straw.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 15247 |
| Date reported | September 17, 2015 |
| Date initiated | September 17, 2015 |
| Recalling firm | Zak Designs Inc., of Airway Heights, Wash. |
| Affected scope | About 178,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using the recalled water bottles and contact Zak Designs for instructions on receiving a free r…
- Check the recall number (15247) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
The recall involves Zak Designs 26-ounce plastic water bottles. The 10-inch-tall water bottles have a flip-top spout on a twist-off cap with colored inner plastic straws in clear, blue, gray, green, light purple or red. The water bottles were sold exclusively at Target stores in a "Back-to-College" promotion. The water bottles have popular characters on the front and come in a variety of colors including clear, gray, navy blue, pink, teal blue, gray with colored caps in red, blue pink and yellow. Characters include Captain America, a Batman design, Minions, My Little Pony, Spiderman, Star Wars aircraft, a Superman logo, Teenage Mutant Ninja Turtles, Thor and Wonder Woman. Mold number "14158" and "Zak Designs®" are embossed on the bottom of the bottles in the recall. Bottles with a black inner straw and black twist-off cap are not included in the recall.. Recalled by Zak Designs Inc., of Airway Heights, Wash.. Units affected: About 178,000.
Why was this product recalled? ▼
The inner plastic straw in the flip-top portion of the twist-off cap can break, posing a choking hazard.
What should consumers do? ▼
Consumers should immediately stop using the recalled water bottles and contact Zak Designs for instructions on receiving a free replacement cap with straw.
Which agency issued this recall? ▼
This recall was issued by the CPSC on September 17, 2015. Severity: Moderate. Recall number: 15247.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (15247) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Cooper Lighting Recalls Metalux Optimized High Bay LED Light Fixtures Due to Fire Hazard
Cooper Lighting, LLC, of Peachtree City, Georgia · 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Roman Candles 8 Shot Fireworks Due to Risk of Serious Injury from Explosion and B…
· 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Unity 7 Shot 200 Gram Aerial Cake Fireworks Due to Risk of Serious Injury from Ex…
· 2026-07-02
CPSC Moderate
Kith Retail Recalls Children's Loungewear Sets Due to Risk of Serious Injury from Burn Hazard; Violate Mandatory Standa…
· 2026-06-25
CPSC Moderate
Southern Telecom Expands Recall of Lomi Waxing Kits Due to Risk of Serious Injury or Death from Fire and Burn Hazards; …
· 2026-06-25
Compare this recall with Cooper Lighting Recalls Metalux Optimized High Bay LED Ligh… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported September 17, 2015. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.