Severity
Moderate
ModerateActive
CPSC recall · Reported December 22, 2015
Carrier Recalls to Repair Packaged Terminal Air Conditioners, Heat Pumps Including Previously Recalled Units Due to Fire Hazard
The power cord plug can overheat, posing a fire hazard to consumers.
Compiled from official public sources by the editorial team.
Verify with CPSC →
Carrier Corporation, of Farmington, Conn. recalled This recall involves Packaged Terminal Air Conditioners (PTAC) and Packaged Terminal Heat… - a moderate-severity action.
Carrier Recalls to Repair Packaged Terminal Air Conditioners, Heat Pumps Including Previo… was recalled by Carrier Corporation, of Farmington, Conn. in December 22, 2015. Reason: The power cord plug can overheat, posing a fire hazard to consumers.. Remedy: Consumers should stop using and unplug the recalled units, and contact Carrier to receive…. Verify recall #16065 with the CPSC before acting.
The recall
Carrier Corporation, of Farmington, Conn. issued this moderate-severity CPSC recall-The power cord plug can overheat, posing a fire hazard to consumers..
- Moderate
- severity level
- December 22, 2015
- reported
Sourced from official CPSC enforcement records. Verify recall #16065 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #16065) was formally reported on December 22, 2015. It is classified under Moderate severity, with a current status of Active. Carrier Corporation, of Farmington, Conn. is listed as the recalling firm. Federal records list the affected scope as About 285,000 (About 185,000 were previously recalled in November 2007).
The documented reason for this recall is: The power cord plug can overheat, posing a fire hazard to consumers. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using and unplug the recalled units, and contact Carrier to receive a free replacement cord. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Household Products recalls over time
Where this recall sits in its category - 3,056 household products recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 285,000 (About 185,000 were previously recalled in November 2007)
Related Recalls
6
6 from same agency
Product description
This recall involves Packaged Terminal Air Conditioners (PTAC) and Packaged Terminal Heat Pumps (PTHP) sold under the Bryant, Carrier and Fast brand names. Recalled units include those with original power cords and those that received a supplemental power cord as part of the 2007 recall. The recalled units have capacities of 7,000; 9,000; 12,000 and 15,000 BTUs and plug into 208/230-volt, 20-amp outlets. The following brands and eight models are being recalled: Carrier models 52CE, 52CQ, 52PE and 52PQ; Bryant models 840 and 841; and Fast models 840 and 841. Model and serial numbers are located on the ratings/data plate on the right front of the unit, underneath the removable front panel. A complete list of the serial numbers involved in this recall is available by calling Carrier or at www.carrier.com.
Reason for recall
The power cord plug can overheat, posing a fire hazard to consumers.
Remedy, what to do
Consumers should stop using and unplug the recalled units, and contact Carrier to receive a free replacement cord.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 16065 |
| Date reported | December 22, 2015 |
| Date initiated | December 22, 2015 |
| Recalling firm | Carrier Corporation, of Farmington, Conn. |
| Affected scope | About 285,000 (About 185,000 were previously recalled in November 2007) |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using and unplug the recalled units, and contact Carrier to receive a free replacement cord.
- Check the recall number (16065) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
This recall involves Packaged Terminal Air Conditioners (PTAC) and Packaged Terminal Heat Pumps (PTHP) sold under the Bryant, Carrier and Fast brand names. Recalled units include those with original power cords and those that received a supplemental power cord as part of the 2007 recall. The recalled units have capacities of 7,000; 9,000; 12,000 and 15,000 BTUs and plug into 208/230-volt, 20-amp outlets. The following brands and eight models are being recalled: Carrier models 52CE, 52CQ, 52PE and 52PQ; Bryant models 840 and 841; and Fast models 840 and 841. Model and serial numbers are located on the ratings/data plate on the right front of the unit, underneath the removable front panel. A complete list of the serial numbers involved in this recall is available by calling Carrier or at www.carrier.com.. Recalled by Carrier Corporation, of Farmington, Conn.. Units affected: About 285,000 (About 185,000 were previously recalled in November 2007).
Why was this product recalled? ▼
The power cord plug can overheat, posing a fire hazard to consumers.
What should consumers do? ▼
Consumers should stop using and unplug the recalled units, and contact Carrier to receive a free replacement cord.
Which agency issued this recall? ▼
This recall was issued by the CPSC on December 22, 2015. Severity: Moderate. Recall number: 16065.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (16065) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Cooper Lighting Recalls Metalux Optimized High Bay LED Light Fixtures Due to Fire Hazard
Cooper Lighting, LLC, of Peachtree City, Georgia · 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Roman Candles 8 Shot Fireworks Due to Risk of Serious Injury from Explosion and B…
· 2026-07-02
CPSC Moderate
Winco Fireworks International Recalls Unity 7 Shot 200 Gram Aerial Cake Fireworks Due to Risk of Serious Injury from Ex…
· 2026-07-02
CPSC Moderate
Kith Retail Recalls Children's Loungewear Sets Due to Risk of Serious Injury from Burn Hazard; Violate Mandatory Standa…
· 2026-06-25
CPSC Moderate
Southern Telecom Expands Recall of Lomi Waxing Kits Due to Risk of Serious Injury or Death from Fire and Burn Hazards; …
· 2026-06-25
Compare this recall with Cooper Lighting Recalls Metalux Optimized High Bay LED Ligh… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported December 22, 2015. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.