NHTSA recall · Reported October 5, 2018
INTERNATIONAL 2018-2019: EXTERIOR LIGHTING:HEADLIGHTS
Truck-Lite Company, LLC (Truck-Lite) is recalling certain right-hand incandescent halogen headlights, part numbers Truck-Lite 27628C, 27628C7, Navistar 4049970C91, 4049970C92, 404…
International recalled Truck-Lite Company, LLC (Truck-Lite) is recalling certain right-hand incandescent halogen….
INTERNATIONAL 2018-2019: EXTERIOR LIGHTING:HEADLIGHTS was recalled by International in October 5, 2018. Reason: Truck-Lite Company, LLC (Truck-Lite) is recalling certain right-hand incandescent halogen headlights, part nu…. Remedy: Truck-Lite will notify owners and will send them a "DOT VOR" label to install, free of ch…. Verify recall #18E094000 with the NHTSA before acting.
The recall
International issued this NHTSA recall-Truck-Lite Company, LLC (Truck-Lite) is recalling certain right-hand incandescent halogen headlights, part nu….
- None
- agency class
- October 5, 2018
- reported
Sourced from official NHTSA enforcement records. Verify recall #18E094000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
Truck-Lite Company, LLC (Truck-Lite) is recalling certain right-hand incandescent halogen headlights, part numbers Truck-Lite 27628C, 27628C7, Navistar 4049970C91, 4049970C92, 4049970C93, and 4049970C94, for installation on Navistar International LT-series trucks. The headlights may have incorrect "VOL" markings when they should be marked as "VOR." These headlights are correctly designed to be visually/optically aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associate d Equipment."
Reason for recall
Truck-Lite Company, LLC (Truck-Lite) is recalling certain right-hand incandescent halogen headlights, part numbers Truck-Lite 27628C, 27628C7, Navistar 4049970C91, 4049970C92, 4049970C93, and 4049970C94, for installation on Navistar International LT-series trucks. The headlights may have incorrect "VOL" markings when they should be marked as "VOR." These headlights are correctly designed to be visually/optically aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associate d Equipment."
Hazard
If the headlights have incorrect markings, when they are replaced, the headlights may be aimed incorrectly, decreasing visibility and increasing the risk of a crash.
Remedy, what to do
Truck-Lite will notify owners and will send them a "DOT VOR" label to install, free of charge. The recall began November 26, 2018. Owners may contact International Trucks Customer Service Center at 1-800-448-7825.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 18E094000 |
| Date reported | October 5, 2018 |
| Date initiated | October 5, 2018 |
| Recalling firm | International |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
Truck-Lite will notify owners and will send them a "DOT VOR" label to install, free of charge. The recall began November 26, 201…
- Check the recall number (18E094000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026