Severity
Not classified by agency
No agency classActive
CPSC recall · Reported February 27, 2019
Harbor Freight Tools Recalls 12V Rechargeable Flashlights Due to Overheating and Burn Hazards
The flashlight can overheat while charging, posing a burn hazard to consumers.
The CPSC recalled This recall involves the Harbor Freight 80 Lumen 12v rechargeable flashlights. The small ….
Harbor Freight Tools Recalls 12V Rechargeable Flashlights Due to Overheating and Burn Haz… was recalled and listed by the CPSC in February 27, 2019. Reason: The flashlight can overheat while charging, posing a burn hazard to consumers.. Remedy: Consumers should immediately stop using the recalled flashlights, and return them to any …. Verify recall #19073 with the CPSC before acting.
The recall
issued this CPSC recall-The flashlight can overheat while charging, posing a burn hazard to consumers..
- None
- agency class
- February 27, 2019
- reported
Sourced from official CPSC enforcement records. Verify recall #19073 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #19073) was formally reported on February 27, 2019. The CPSC does not publish a hazard classification for its recalls, so this record carries no agency severity grade, with a current status of Active. The recalling firm is not specified in the federal record. Federal records list the affected scope as About 500,000.
The documented reason for this recall is: The flashlight can overheat while charging, posing a burn hazard to consumers. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using the recalled flashlights, and return them to any Harbor Freight Tools location for a refund in the form of a $5 Harbor Freight Tools gift card. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 2 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,782 vehicles recalls on record
Affected scope
About 500,000
Related Recalls
6
2 from same agency
Product description
This recall involves the Harbor Freight 80 Lumen 12v rechargeable flashlights. The small black flashlight has a soft white button located on the side to turn the flashlight on and off. The base of the flashlight is a charger that fits into any standard vehicle 12V power port to charge. The recalled flashlight's SKU number is 64109 and can be found on the sticker label that also bears the product barcode. The flashlight is approximately 5 inches long.
Reason for recall
The flashlight can overheat while charging, posing a burn hazard to consumers.
Remedy, what to do
Consumers should immediately stop using the recalled flashlights, and return them to any Harbor Freight Tools location for a refund in the form of a $5 Harbor Freight Tools gift card.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 19073 |
| Date reported | February 27, 2019 |
| Date initiated | February 27, 2019 |
| Recalling firm | Not disclosed |
| Affected scope | About 500,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using the recalled flashlights, and return them to any Harbor Freight Tools location for a refu…
- Check the recall number (19073) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
This recall involves the Harbor Freight 80 Lumen 12v rechargeable flashlights. The small black flashlight has a soft white button located on the side to turn the flashlight on and off. The base of the flashlight is a charger that fits into any standard vehicle 12V power port to charge. The recalled flashlight's SKU number is 64109 and can be found on the sticker label that also bears the product barcode. The flashlight is approximately 5 inches long.. Units affected: About 500,000.
Why was this product recalled? ▼
The flashlight can overheat while charging, posing a burn hazard to consumers.
What should consumers do? ▼
Consumers should immediately stop using the recalled flashlights, and return them to any Harbor Freight Tools location for a refund in the form of a $5 Harbor Freight Tools gift card.
Which agency issued this recall? ▼
This recall was issued by the CPSC on February 27, 2019. CPSC does not publish a hazard classification for this recall. Recall number: 19073.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (19073) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nationwide recalls with similar severity or category timing
Two federal-filing-derived peer sets for this notice, both outside the same recalling firm and filing state so the neighborhoods are not firm or geographic containment.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
Showing 5 of 8939 other recalls in this category.
CPSC No agency class
Vanderhall North America Recalls Brawley GTS Electric Recreational Off Highway Vehicles (ROVs) Due to Risk of Serious I…
Vanderhall North America, LLC, of Provo, Utah · 2026-08-06
NHTSA No agency class
ALFA ROMEO,DODGE 2023-2024: SEAT BELTS:FRONT:RETRACTOR
ALFA ROMEO,DODGE · 2026-08-06
CPSC No agency class
Trsmima Zipline Kits and Zipline Spring Brakes Recalled Due to Fall and Collision Hazards; Manufactured by Trsmima
HuNanBoLuoDianZiShangWuYouXianGongSi D/B/A Trsmima or Hunan Pineapple Electronic Commerce Co., Ltd., of China · 2026-07-30
NHTSA No agency class
HONDA 2017-2023: STEERING: STEERING WHEEL/HANDLE BAR
HONDA · 2026-07-30
NHTSA No agency class
CHEVROLET,GMC 2026: WHEELS
CHEVROLET,GMC · 2026-07-30
Compare this recall with Vanderhall North America Recalls Brawley GTS Electric Recre… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported February 27, 2019. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.