CPSC recall · Reported September 30, 2020
Petzl Recalls Safety Ropes Due to Fall and Injury Hazard
The rope can have a deep cut or tape securing two ends of rope together, which can cause the rope to fail, posing fall and injury hazards to the user.
The CPSC recalled The recalled low-stretch kernmantle ropes are designed for professional use, including wo….
Petzl Recalls Safety Ropes Due to Fall and Injury Hazard was recalled and listed by the CPSC in September 30, 2020. Reason: The rope can have a deep cut or tape securing two ends of rope together, which can cause the rope to fail, po…. Remedy: Consumers should immediately stop using the recalled ropes and inspect the rope for a dee…. Verify recall #20194 with the CPSC before acting.
The recall
issued this CPSC recall-The rope can have a deep cut or tape securing two ends of rope together, which can cause the rope to fail, po….
- None
- agency class
- September 30, 2020
- reported
Sourced from official CPSC enforcement records. Verify recall #20194 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Outdoor & Sports recalls over time
Where this recall sits in its category - 515 outdoor & sports recalls on record
Product description
The recalled low-stretch kernmantle ropes are designed for professional use, including work-at-height use, difficult access, technical rescue and industrial applications; and for recreational use, including climbing, caving and mountaineering. The ropes have a nylon core and polyester sheath material. Only ropes with serial numbers ranging between 18 C 0000000 000 and 20 H 0000000 000 are included in the recall. The recalled rope models include: Axis 11mm rope (white, yellow, black, blue, red and orange) available in 150, 200, 600 and 1200 feet. Model Numbers R074AA00 - R074AA27. Parallel 10.5mm (white, yellow, black, blue, red and orange), available in 50, 100, 200 and 500 meters. Model Numbers R077AA03 - R077AA28. Vector 12.5mm rope (white, yellow, black, blue, red and orange) available in 150, 200, 600 and 1200 feet. Model Numbers R078AA00-R078AA27. Segment 8 mm (white) available in 50, 100 or 200 meters. Model Numbers R076AA00 - R076AA06. Ray 12 mm (yellow/black) available in 25, 50, 75, 100 and 200 feet. Model Numbers R091AA00 - R091AA04. ASAP'AXIS 11 mm (white) available 10, 20, 30, 40, 50 and 60 meters. Model numbers R074DA00 -- R074DA05 Push 200 9 mm (white, orange) available in 200 meters. Model Numbers R40AW200 and R40AO200. Club 200 10 mm (white, orange) available in 200 meters. Model Numbers R39AW200 and R39AO200. Top 9.8 mm (Not sold in North America) Lead 9.8mm (Not sold in North America) JAG Rescue Kit model numbers K090AA00-K090AA02 The recalled safety ropes have the model name and serial number on the label affixed to each end of the rope.
Reason for recall
The rope can have a deep cut or tape securing two ends of rope together, which can cause the rope to fail, posing fall and injury hazards to the user.
Remedy, what to do
Consumers should immediately stop using the recalled ropes and inspect the rope for a deep cut or tape connecting two ends of rope together, and if either is found, contact Petzl America for instructions on receiving a free replacement rope.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 20194 |
| Date reported | September 30, 2020 |
| Date initiated | September 30, 2020 |
| Recalling firm | Not disclosed |
| Affected scope | About 14,850 (In addition, about 2,500 were sold in Canada) |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using the recalled ropes and inspect the rope for a deep cut or tape connecting two ends of rop…
- Check the recall number (20194) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Outdoor & Sports · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with Southern Telecom Recalls Brookstone-Branded Tabletop Fire P… → · All Outdoor & Sports recalls
Methodology · Corrections · Archive as of August 2026