NHTSA recall · Reported July 27, 2020
MERCEDES-BENZ 2019: SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:LEAF
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between…
Mercedes-benz recalled Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freigh….
MERCEDES-BENZ 2019: SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:LEAF was recalled by Mercedes-benz in July 27, 2020. Reason: Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehi…. Remedy: DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, r…. Verify recall #20V426000 with the NHTSA before acting.
The recall
Mercedes-benz issued this NHTSA recall-Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehi….
- None
- agency class
- July 27, 2020
- reported
Sourced from official NHTSA enforcement records. Verify recall #20V426000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Reason for recall
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Hazard
The incorrect leaf spring shims may negatively affect vehicle handling, increasing the risk of a crash.
Remedy, what to do
DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubber buffers for wear, renewing them if necessary, and adjust the headlamps, free of charge. The manufacturer has not yet provided a schedule for recall notification. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LE
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 20V426000 |
| Date reported | July 27, 2020 |
| Date initiated | July 27, 2020 |
| Recalling firm | Mercedes-benz |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubb…
- Check the recall number (20V426000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026