CPSC recall · Reported January 12, 2023
American Honda Expands Recall of Honda Talon 1000 ROVs Due to Crash and Injury Hazards
The vehicle's intake funnel band screw can loosen and enter the engine through the intake funnel and cause sudden engine failure. If this occurs, it can result in a loss of contro…
American Honda Motor Co. Inc., of Torrance, California recalled This recall expansion involves an additional 2,000 2021 model year Honda Talon 1000 side-….
American Honda Expands Recall of Honda Talon 1000 ROVs Due to Crash and Injury Hazards was recalled by American Honda Motor Co. Inc., of Torrance, California in January 12, 2023. Reason: The vehicle's intake funnel band screw can loosen and enter the engine through the intake funnel and cause su…. Remedy: Consumers should immediately stop using the recalled recreational off-highway vehicles an…. Verify recall #23090 with the CPSC before acting.
The recall
American Honda Motor Co. Inc., of Torrance, California issued this CPSC recall-The vehicle's intake funnel band screw can loosen and enter the engine through the intake funnel and cause su….
- None
- agency class
- January 12, 2023
- reported
Sourced from official CPSC enforcement records. Verify recall #23090 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
This recall expansion involves an additional 2,000 2021 model year Honda Talon 1000 side-by-sides with model numbers Talon 1000 S2 and Talon 1000 S4. The vehicles were sold in various colors including red, blue, green, gray and yellow. "HONDA" is printed on the front, sides and the rear of each vehicle. "Talon" is printed on a label located on both sides of the vehicle. The Vehicle Identification Number (VIN) number is stamped on the frame on the left side under the left front fender. The VIN range for affected Talon 1000s is as shown below. Original Recall: MY Model VIN Start VIN End 2019 Talon 1000 S2 1HFVE05**K4000003 1HFVE05**K4003902 2020 Talon 1000 S2 1HFVE05**L4100001 1HFVE05**L4102280 2021 Talon 1000 S2 1HFVE05**M4200001 1HFVE05**M4202760 2020 Talon 1000 S4 1HFVE06**L4000002 1HFVE06**L4003420 2021 Talon 1000 S4 1HFVE06**M4100001 1HFVE06**M4102218 Expanded Recall: : MY Model VIN Start VIN End 2019 Talon 1000 S2 1HFVE05**M4200084 1HFVE05**M4203061 2020 Talon 1000 S4 1HFVE06**M4100121 1HFVE06**M4102580
Reason for recall
The vehicle's intake funnel band screw can loosen and enter the engine through the intake funnel and cause sudden engine failure. If this occurs, it can result in a loss of control, increasing the risk of a crash or injury.
Remedy, what to do
Consumers should immediately stop using the recalled recreational off-highway vehicles and contact an authorized Honda Powersports dealer to schedule an appointment for a free inspection and repair, which includes proper tightening and thread deformation of the intake funnel screw. American Honda is contacting all known purchasers directly.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 23090 |
| Date reported | January 12, 2023 |
| Date initiated | January 12, 2023 |
| Recalling firm | American Honda Motor Co. Inc., of Torrance, California |
| Affected scope | About 34,000 (About 32,000 were previously recalled in March 2022) |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using the recalled recreational off-highway vehicles and contact an authorized Honda Powersport…
- Check the recall number (23090) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026