Arctic Cat Recalls Snowmobiles Due to Laceration Hazard

Recall Insight

This CPSC action (record #24223) was formally reported on May 2, 2024. It is classified under Moderate severity, with a current status of Active. Arctic Cat, of Thief River Falls, Minnesota is listed as the recalling firm. Federal records indicate About 16,200 units are affected.

The documented reason for this recall is: The recalled snowmobile's drive clutch can break, allowing fragments to escape the snowmobile shielding, posing a laceration hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using the recalled snowmobiles, and contact Arctic Cat to schedule for a free installation of an additional clutch guard and inspection of the primary clutch. If the… — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 2 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.