CPSC recall · Reported February 20, 2025
SuperATV Recalls Carrier Bearings for Polaris RZR XP and Turbo S Recreational Off Highway Vehicles Due to Fire and Burn Hazards
When the recalled carrier bearings are installed in a Polaris RZR XP Turbo or Turbo S vehicle and the fuel tank expands, the drive shaft can come in contact with the fuel tank, ca…
SuperATV, of Madison, Indiana recalled This recall involves three models of SuperATV carrier bearings sold from April 2017 until….
SuperATV Recalls Carrier Bearings for Polaris RZR XP and Turbo S Recreational Off Highway… was recalled by SuperATV, of Madison, Indiana in February 20, 2025. Reason: When the recalled carrier bearings are installed in a Polaris RZR XP Turbo or Turbo S vehicle and the fuel ta…. Remedy: Consumers should immediately stop using ROVs with the recalled carrier bearings, remove t…. Verify recall #25150 with the CPSC before acting.
The recall
SuperATV, of Madison, Indiana issued this CPSC recall-When the recalled carrier bearings are installed in a Polaris RZR XP Turbo or Turbo S vehicle and the fuel ta….
- None
- agency class
- February 20, 2025
- reported
Sourced from official CPSC enforcement records. Verify recall #25150 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
This recall involves three models of SuperATV carrier bearings sold from April 2017 until September 2022 for installation in Polaris RZR XP Turbo or Turbo S vehicles. The recalled carrier bearings are silver and black and have "SuperATV" etched on top of the carrier bearing housing. The carrier bearing is located under the center console tunnel which is behind the seats on the two-seat model and behind the rear seats on the four-seat models. The following carrier bearing models are subject to this recall if purchased for the Polaris RZR XP Turbo or Turbo S vehicles in the identified date ranges: RECALLED CARRIER BEARING MODEL POLARIS RZR XP TURBO OR TURBO S PURCHASE DATE RANGE BEA01-001 4/13/17 through 4/27/19 BEA01-002 5/19/18 through 1/22/19 BEA01-005 (Rev A00 and A01) 1/25/19 through 9/2/22
Reason for recall
When the recalled carrier bearings are installed in a Polaris RZR XP Turbo or Turbo S vehicle and the fuel tank expands, the drive shaft can come in contact with the fuel tank, causing the tank to develop a hole or crack. This can cause the fuel tank to leak gasoline, posing fire and burn hazards.
Remedy, what to do
Consumers should immediately stop using ROVs with the recalled carrier bearings, remove them from the Polaris RZR XP Turbo or Turbo S vehicles, and register online at https://form.jotform.com/243023918871055 to receive a postage-paid label to return the recalled bearings. SuperATV will mail consumers free replacement carrier bearings upon receipt of the recalled carrier bearings. SuperATV is notifying all known purchasers directly. No purchase receipt is required.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 25150 |
| Date reported | February 20, 2025 |
| Date initiated | February 20, 2025 |
| Recalling firm | SuperATV, of Madison, Indiana |
| Affected scope | About 10,700 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using ROVs with the recalled carrier bearings, remove them from the Polaris RZR XP Turbo or Tur…
- Check the recall number (25150) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026