CPSC, NHTSA, and Dorel Juvenile Group Inc. Announce Extended Recall of Infant Car Seats/Carriers

Recall Insight

This CPSC action (record #03148) was formally reported on June 25, 2003. It is classified under Moderate severity, with a current status of Active. Dorel Juvenile Group Inc., of Columbus, Ind. is listed as the recalling firm. Federal records indicate 1.2 million units are affected.

The documented reason for this recall is: When the seat is used as a carrier, the plastic handle locks can unexpectedly break or release from the carrying position, causing the seat to unlatch or flip forward. When this happens, an infant can fall to the ground… Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should continue to use the Arriva and Turnabout as a car seat but should stop using it as a carrier immediately and contact Dorel Juvenile Group to receive a free repair kit. — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 1 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 23 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.