NHTSA recall · Reported October 4, 2005
VOLVO 2006: POWER TRAIN:AXLE ASSEMBLY
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME OF THE SPINDLES WERE OVERHEATED DURING THE HEAT TREAT PROCESS WHICH COULD RESULT IN A FRACT…
Volvo recalled ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME O….
VOLVO 2006: POWER TRAIN:AXLE ASSEMBLY was recalled by Volvo in October 4, 2005. Reason: ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME OF THE SPINDLES WERE …. Remedy: DEALERS WILL INSPECT THE SPINDLE FOR SUSPECT HEAT CODES AND REPLACE THE AXLE IF NECESSARY…. Verify recall #05V457000 with the NHTSA before acting.
The recall
Volvo issued this NHTSA recall-ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME OF THE SPINDLES WERE ….
- None
- agency class
- October 4, 2005
- reported
Sourced from official NHTSA enforcement records. Verify recall #05V457000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This NHTSA action (record #05V457000) was formally reported on October 4, 2005. The NHTSA does not publish a hazard classification for its recalls, so this record carries no agency severity grade, with a current status of Active. Volvo is listed as the recalling firm. The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts.
The documented reason for this recall is: ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME OF THE SPINDLES WERE OVERHEATED DURING THE HEAT TREAT PROCESS WHICH COULD RESULT IN A FRACTURE OF THE SPINDLE. The specific hazard cited in the filing is: IF A SPINDLE FRACTURES WHILE THE VEHICLE IS IN MOTION, IT MAY CAUSE WHEEL SEPARATION, WHICH COULD, WITHOUT WARNING RESULT IN A VEHICLE CRASH.. Distribution data in the federal record shows the product reached: United States. Distribution scope directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. The remedy documented by the agency is: DEALERS WILL INSPECT THE SPINDLE FOR SUSPECT HEAT CODES AND REPLACE THE AXLE IF NECESSARY. THE RECALL BEGAN ON DECEMBER 12, 2005. OWNERS MAY CONTACT VOVLO TRUCKS AT 1-800-528-6586. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 4 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,782 vehicles recalls on record
Product description
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME OF THE SPINDLES WERE OVERHEATED DURING THE HEAT TREAT PROCESS WHICH COULD RESULT IN A FRACTURE OF THE SPINDLE.
Reason for recall
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR SERIES 145 AND 160 REAR DRIVE AXLES. SOME OF THE SPINDLES WERE OVERHEATED DURING THE HEAT TREAT PROCESS WHICH COULD RESULT IN A FRACTURE OF THE SPINDLE.
Hazard
IF A SPINDLE FRACTURES WHILE THE VEHICLE IS IN MOTION, IT MAY CAUSE WHEEL SEPARATION, WHICH COULD, WITHOUT WARNING RESULT IN A VEHICLE CRASH.
Remedy, what to do
DEALERS WILL INSPECT THE SPINDLE FOR SUSPECT HEAT CODES AND REPLACE THE AXLE IF NECESSARY. THE RECALL BEGAN ON DECEMBER 12, 2005. OWNERS MAY CONTACT VOVLO TRUCKS AT 1-800-528-6586.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 05V457000 |
| Date reported | October 4, 2005 |
| Date initiated | October 4, 2005 |
| Recalling firm | Volvo |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
DEALERS WILL INSPECT THE SPINDLE FOR SUSPECT HEAT CODES AND REPLACE THE AXLE IF NECESSARY. THE RECALL BEGAN ON DECEMBER 12, 2005…
- Check the recall number (05V457000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with Vanderhall North America Recalls Brawley GTS Electric Recre… → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026