Severity
Moderate
ModerateActive
CPSC recall · Reported April 25, 2007
Acer America Corporation Recalls Notebook Computer Batteries Due to Previous Fires
The lithium-ion batteries can overheat, posing a fire hazard to consumers.
Compiled from official public sources by the editorial team.
Verify with CPSC →
Acer Inc., of Taiwan (computers) recalled Only lithium-ion batteries with the following part numbers and battery week codes and use… - a moderate-severity action.
Acer America Corporation Recalls Notebook Computer Batteries Due to Previous Fires was recalled by Acer Inc., of Taiwan (computers) in April 25, 2007. Reason: The lithium-ion batteries can overheat, posing a fire hazard to consumers.. Remedy: Consumers should stop using these recalled batteries immediately and contact Acer to rece…. Verify recall #07167 with the CPSC before acting.
The recall
Acer Inc., of Taiwan (computers) issued this moderate-severity CPSC recall-The lithium-ion batteries can overheat, posing a fire hazard to consumers..
- Moderate
- severity level
- April 25, 2007
- reported
Sourced from official CPSC enforcement records. Verify recall #07167 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #07167) was formally reported on April 25, 2007. It is classified under Moderate severity, with a current status of Active. Acer Inc., of Taiwan (computers) is listed as the recalling firm. Federal records list the affected scope as About 27,800.
The documented reason for this recall is: The lithium-ion batteries can overheat, posing a fire hazard to consumers. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using these recalled batteries immediately and contact Acer to receive a free replacement battery. Consumers can continue to use the notebook computers safely by turning the sys… - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Electronics recalls over time
Where this recall sits in its category - 609 electronics recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 27,800
Related Recalls
6
6 from same agency
Product description
Only lithium-ion batteries with the following part numbers and battery week codes and used in the following Acer notebook models, are included in the recall: Acer Notebook System Series Beginning with: Acer Battery Pack No. (Part of Barcode) Battery Pack Serial Week Code Range (Part of Barcode) Battery Week Code Range (in front of Barcode) Battery Week Code Range on Red Sticker TravelMate 321x BT00604001 0521-0545 Aspire 980x BT00804016 63V, 63W, 63X, 63Y TravelMate 242x, TravelMate 330x Aspire 556x BT00604005 601-626 TravelMate 561x Aspire 930x, Aspire 941x BT00807010 614-630 TravelMate C20x BT00604002 5BR-5BZ; 5C1-5C9; 5CA-5CZ; 611-619; 621-629; 62A TravelMate 422x, TravelMate 467x Aspire 560x, Aspire 567x BT00804011 0551-0626 TravelMate 320x BTT4807001 418-552
Reason for recall
The lithium-ion batteries can overheat, posing a fire hazard to consumers.
Remedy, what to do
Consumers should stop using these recalled batteries immediately and contact Acer to receive a free replacement battery. Consumers can continue to use the notebook computers safely by turning the system off, removing the battery, and using the AC adapter and power cord to power the system until the replacement battery is received.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 07167 |
| Date reported | April 25, 2007 |
| Date initiated | April 25, 2007 |
| Recalling firm | Acer Inc., of Taiwan (computers) |
| Affected scope | About 27,800 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using these recalled batteries immediately and contact Acer to receive a free replacement battery. Consumer…
- Check the recall number (07167) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Only lithium-ion batteries with the following part numbers and battery week codes and used in the following Acer notebook models, are included in the recall: Acer Notebook System Series Beginning with: Acer Battery Pack No. (Part of Barcode) Battery Pack Serial Week Code Range (Part of Barcode) Battery Week Code Range (in front of Barcode) Battery Week Code Range on Red Sticker TravelMate 321x BT00604001 0521-0545 Aspire 980x BT00804016 63V, 63W, 63X, 63Y TravelMate 242x, TravelMate 330x Aspire 556x BT00604005 601-626 TravelMate 561x Aspire 930x, Aspire 941x BT00807010 614-630 TravelMate C20x BT00604002 5BR-5BZ; 5C1-5C9; 5CA-5CZ; 611-619; 621-629; 62A TravelMate 422x, TravelMate 467x Aspire 560x, Aspire 567x BT00804011 0551-0626 TravelMate 320x BTT4807001 418-552. Recalled by Acer Inc., of Taiwan (computers). Units affected: About 27,800.
Why was this product recalled? ▼
The lithium-ion batteries can overheat, posing a fire hazard to consumers.
What should consumers do? ▼
Consumers should stop using these recalled batteries immediately and contact Acer to receive a free replacement battery. Consumers can continue to use the notebook computers safely by turning the system off, removing the battery, and using the AC adapter and power cord to power the system until the replacement battery is received.
Which agency issued this recall? ▼
This recall was issued by the CPSC on April 25, 2007. Severity: Moderate. Recall number: 07167.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (07167) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Projecting LED Finger Light Toys Recalled Due to Risk of Serious Injury Death from Battery Ingestion; Violate Mandatory…
Shenzhen Bopu Product Design Co., Ltd., dba POPOOO, of China · 2026-07-02
CPSC Moderate
Combination Smoke and Carbon Monoxide (CO) Detectors Recalled Due to Risk of Serious Injury or Death from Failure to Al…
· 2026-06-25
CPSC Moderate
Raychy Children's Light Sneakers Recalled Due to Risk of Serious Injury or Death from Battery Ingestion; Violate Mandat…
· 2026-06-25
CPSC Moderate
Super Off-Road Solar Power Banks Recalled Due to Overheating; Imported by Spector & Co.
· 2026-06-25
CPSC Moderate
School Specialty Recalls Tip Restraint Kits Included in Childcraft Furniture Due to Risk of Serious Injury or Death fro…
School Specialty, LLC, of Greenville, Wisconsin · 2026-06-11
Compare this recall with Projecting LED Finger Light Toys Recalled Due to Risk of Se… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported April 25, 2007. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.