Nitrous Oxide Systems Recalls Snowmobile and ATV NOS Kit Bottles that Can Forcefully Burst

Recall Insight

This CPSC action (record #07515) was formally reported on January 3, 2007. It is classified under Moderate severity, with a current status of Active. Nitrous Oxide Systems, of Bowling Green, Ky. is listed as the recalling firm. Federal records indicate About 16 units are affected.

The documented reason for this recall is: An incorrect burst disc, a component of the NOS bottle valve, may have been installed in the recalled NOS Kits. If the bottle is overfilled and overheated, it could forcefully burst, posing an impact injury hazard to co… Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using the recalled NOS system for snowmobiles and ATVs immediately and contact NOS to have the burst disc replaced. Registered owners have been notified about this recall by mai… — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 1 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 19 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.