CPSC recall · Reported September 11, 2008
PB Heat Recalls Gas Boilers Due to Carbon Monoxide Hazard
The pressure switch could have an internal defect that could fail to shut down the boilers under vent or air inlet blockage. This switch defect could allow the boilers to produce …
Pb Heat LLC, of Bally, Pa. recalled This recall involves the DE and PSC II Gas Fired Cast Iron Boilers with the Endura Plasti….
PB Heat Recalls Gas Boilers Due to Carbon Monoxide Hazard was recalled by Pb Heat LLC, of Bally, Pa. in September 11, 2008. Reason: The pressure switch could have an internal defect that could fail to shut down the boilers under vent or air …. Remedy: Consumers who have not already been contacted, should contact their installer immediately…. Verify recall #08397 with the CPSC before acting.
The recall
Pb Heat LLC, of Bally, Pa. issued this CPSC recall-The pressure switch could have an internal defect that could fail to shut down the boilers under vent or air ….
- None
- agency class
- September 11, 2008
- reported
Sourced from official CPSC enforcement records. Verify recall #08397 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This recall's affected scope, documented in the Recall Profile below, stays within a single-region or limited-distribution footprint. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Food recalls over time
Where this recall sits in its category - 25,457 food recalls on record
Product description
This recall involves the DE and PSC II Gas Fired Cast Iron Boilers with the Endura Plastics Model ES2035 pressure switch used for home heating and domestic hot water heating. The boilers were available in either natural or LP gas. The boiler rating label is located on the top jacket panel on Series PSCII models and the left side jacket panel on the Series DE models. The label includes the model and serial number. The following model names and serial numbers are included in the recall: Model Name Serial Number DE-03, DE-04, DE-05 and DE-06 5040768 to 5052860 PSCII-03, PSCII-04, PSCII-05, and PSCII-06 5040777 to 5052166 Other suffix designation may follow the base model number, such as SV-WPC.
Reason for recall
The pressure switch could have an internal defect that could fail to shut down the boilers under vent or air inlet blockage. This switch defect could allow the boilers to produce excessive levels of carbon monoxide, posing a risk of carbon monoxide poisoning to consumers.
Remedy, what to do
Consumers who have not already been contacted, should contact their installer immediately for a free safety inspection and repair, if necessary.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 08397 |
| Date reported | September 11, 2008 |
| Date initiated | September 11, 2008 |
| Recalling firm | Pb Heat LLC, of Bally, Pa. |
| Affected scope | About 1,200 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers who have not already been contacted, should contact their installer immediately for a free safety inspection and repair…
- Check the recall number (08397) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Consumer-product notices outside this firm and state, matched by severity timing and product category.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Food · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with Grade A White In-shell Chicken eggs packaged in the followi… → · All Food recalls
Methodology · Corrections · Archive as of August 2026