Severity
Moderate
ModerateActive
CPSC recall · Reported April 14, 2011
ADP Recalls to Repair Unit Heaters Due to Fire Hazard1
Some heaters were manufactured without a required flame rollout switch, which is a back-up device that shuts down the heater in the event of a heater failure. This poses a fire ha…
Compiled from official public sources by the editorial team.
Verify with CPSC →
Lennox Industries Inc., of Richardson, Texas recalled This recall involves ADP FOA series unit heaters with heating capacity, model and serial … - a moderate-severity action.
ADP Recalls to Repair Unit Heaters Due to Fire Hazard1 was recalled by Lennox Industries Inc., of Richardson, Texas in April 14, 2011. Reason: Some heaters were manufactured without a required flame rollout switch, which is a back-up device that shuts …. Remedy: Consumers should stop using these recalled heaters immediately. Consumers should contact …. Verify recall #11198 with the CPSC before acting.
The recall
Lennox Industries Inc., of Richardson, Texas issued this moderate-severity CPSC recall-Some heaters were manufactured without a required flame rollout switch, which is a back-up device that shuts ….
- Moderate
- severity level
- April 14, 2011
- reported
Sourced from official CPSC enforcement records. Verify recall #11198 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #11198) was formally reported on April 14, 2011. It is classified under Moderate severity, with a current status of Active. Lennox Industries Inc., of Richardson, Texas is listed as the recalling firm. Federal records list the affected scope as About 400.
The documented reason for this recall is: Some heaters were manufactured without a required flame rollout switch, which is a back-up device that shuts down the heater in the event of a heater failure. This poses a fire hazard. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should stop using these recalled heaters immediately. Consumers should contact ADP to schedule an inspection and, if necessary, repair of the heater. - consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from CPSC - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Medical Devices recalls over time
Where this recall sits in its category - 40,322 medical devices recalls on record
Of 101,704 recalls in the database, 24,878 are high severity, 72,426 moderate, and 4,400 low. This recall is classified moderate severity.
Counts reflect market size and reporting activity, not inherent danger, we do not rank products by risk from raw recall volume.
Affected scope
About 400
Related Recalls
6
3 from same agency
Product description
This recall involves ADP FOA series unit heaters with heating capacity, model and serial numbers listed below. These unit heaters are separated combustion and gas-fired. The brand name "ADP", the model number and the serial number can be found on the nameplate located inside the control cabinet. Heating Capacity Model Number Serial Number Range 60,000 BTUH FOAN-60-1-1-1 5609K#### to 5610M##### 100,000 BTUH FOAN-100-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L##### 100,000 BTUH FOAP-100-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L##### 125,000 BTUH FOAN-125-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L##### 125,000 BTUH FOAP-125-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L#####
Reason for recall
Some heaters were manufactured without a required flame rollout switch, which is a back-up device that shuts down the heater in the event of a heater failure. This poses a fire hazard.
Remedy, what to do
Consumers should stop using these recalled heaters immediately. Consumers should contact ADP to schedule an inspection and, if necessary, repair of the heater.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 11198 |
| Date reported | April 14, 2011 |
| Date initiated | April 14, 2011 |
| Recalling firm | Lennox Industries Inc., of Richardson, Texas |
| Affected scope | About 400 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should stop using these recalled heaters immediately. Consumers should contact ADP to schedule an inspection and, if ne…
- Check the recall number (11198) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
This recall involves ADP FOA series unit heaters with heating capacity, model and serial numbers listed below. These unit heaters are separated combustion and gas-fired. The brand name "ADP", the model number and the serial number can be found on the nameplate located inside the control cabinet. Heating Capacity Model Number Serial Number Range 60,000 BTUH FOAN-60-1-1-1 5609K#### to 5610M##### 100,000 BTUH FOAN-100-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L##### 100,000 BTUH FOAP-100-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L##### 125,000 BTUH FOAN-125-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L##### 125,000 BTUH FOAP-125-1-1-1 6003J#### to 6010L##### 5603J#### to 5610L#####. Recalled by Lennox Industries Inc., of Richardson, Texas. Units affected: About 400.
Why was this product recalled? ▼
Some heaters were manufactured without a required flame rollout switch, which is a back-up device that shuts down the heater in the event of a heater failure. This poses a fire hazard.
What should consumers do? ▼
Consumers should stop using these recalled heaters immediately. Consumers should contact ADP to schedule an inspection and, if necessary, repair of the heater.
Which agency issued this recall? ▼
This recall was issued by the CPSC on April 14, 2011. Severity: Moderate. Recall number: 11198.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (11198) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Nearby Recalls in This Category
Other recalls in the same product category, useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
Rowenta Recalls Cordless Vacuum Cleaners Due to Risk of Serious Injury from Fire and Burn Hazards
· 2026-07-02
CPSC Moderate
Daikin Comfort Technologies Manufacturing Recalls Amana Air Conditioners and Heat Pumps Due to Risk of Serious Injury f…
· 2026-06-25
CPSC Moderate
Arizer Solo III Portable Vaporizers Recalled Due to Fire and Burn Hazards; Risk of Serious Injury or Death; Imported by…
· 2026-06-18
FDA Devices Moderate
GE HealthCare TRADE IN CARESCAPE TELEMETRY SERVER ARK-2250L - NORTH AMERICA, REF #5697603-902, Product Code KSA; used i…
GE Medical Systems Information Technologies Inc · 2026-06-03
FDA Devices Critical
Medline kits containing Huons Co. Bupivacaine HCL in Dextrose Injection, USP, labeled as: 1) BLOCK TRAY, Medline Kit…
Medline Industries, LP · 2026-06-03
Compare this recall with Rowenta Recalls Cordless Vacuum Cleaners Due to Risk of Ser… →
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records, no number is typed in by an editor. This recall: CPSC, reported April 14, 2011. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of July 2026.