BRP Recalls ATVs Due to Loss of Control Hazard

Recall Insight

This CPSC action (record #12709) was formally reported on December 22, 2011. It is classified under Moderate severity, with a current status of Active. BRP Mexico S.A. de C.V., Ciudad Juárez, Mexican state of Chihuahua is listed as the recalling firm. Federal records indicate About 1,600 units are affected.

The documented reason for this recall is: The Dynamic Power Steering (DPS) main shaft can crack and pieces can detach. Those pieces inside the DPS can block gears and cause limited steering ability, posing a loss of control hazard with risk of serious injury or… Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using the recalled ATVs and contact their local Can-Am ATV dealer to schedule a free repair. BRP will contact registered owners directly. — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 1 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 15 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.