Severity
Moderate
ModerateActive
CPSC recall · Reported March 25, 2016
Specialized Bicycle Components Recalls Headlights and Taillights Due to Fire and Burn Hazards
The headlights and taillights can overheat, posing fire and burn hazards.
The recall
issued this moderate-severity CPSC recall — The headlights and taillights can overheat, posing fire and burn hazards..
- Moderate
- severity level
- March 25, 2016
- reported
Sourced from official CPSC enforcement records. Verify recall #16128 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
This CPSC action (record #16128) was formally reported on March 25, 2016. It is classified under Moderate severity, with a current status of Active. The recalling firm is not specified in the federal record. Federal records list the affected scope as About 110,000.
The documented reason for this recall is: The headlights and taillights can overheat, posing fire and burn hazards. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately stop using these recalled headlights and taillights. Return them an authorized Specialized bicycle retailer for a free repair for Flux model headlights, or a free replace… — consumers holding this product should act on that instruction rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 6 from CPSC — clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Electronics recalls over time
Where this recall sits in its category — 515 electronics recalls on record
Where this recall sits in the database
Of 100,165 recalls in the database, 23,668 are high severity, 72,097 moderate, and 4,400 low. This recall is classified moderate severity.
Affected scope
About 110,000
Related Recalls
6
6 from same agency
Product description
The recall includes Specialized Flux and Stix Sport and Comp model bicycle headlights and taillights sold separately as aftermarket equipment. They have rechargeable batteries with USB ports. Flux headlights: Flux headlights have a round, metal mounting system that fits both flat and drop handlebars. "Flux" is printed on the side of the black, rectangular-shaped lights and on the bottom of the pewter-colored aluminum casing. Flux taillights: Flux taillights have a pewter-colored base with a 110-lumen light on the top. They mount on 27.2 mm, 30.9 mm and Venge seat posts. The Specialized logo is printed on top of the taillights. They have a sensor to boost output in flash mode during the daytime. Stix headlights: Stix headlights are black with a 70-lumen light (Stix Sport) or a 105-lumen light (Stix Comp). They mount on handlebars between 22.2 mm and 35 mm in diameter. Stix is printed in white letters on the end of the headlight.
Reason for recall
The headlights and taillights can overheat, posing fire and burn hazards.
Remedy — what to do
Consumers should immediately stop using these recalled headlights and taillights. Return them an authorized Specialized bicycle retailer for a free repair for Flux model headlights, or a free replacement for Flux model taillights, and Stix model headlights and taillights. Consumers who bought the bicycle lights directly from Specialized should contact Specialized for return instructions.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | U.S. Consumer Product Safety Commission |
| Severity class | Moderate |
| Status | Active |
| Recall number | 16128 |
| Date reported | March 25, 2016 |
| Date initiated | March 25, 2016 |
| Recalling firm | Not disclosed |
| Affected scope | About 110,000 |
| Distribution | Not disclosed |
| Official source | CPSC notice → |
Profile values are sourced directly from the official CPSC enforcement record. Source: U.S. Consumer Product Safety Commission.
What to do with this recall
Consumers should immediately stop using these recalled headlights and taillights. Return them an authorized Specialized bicycle r…
- Check the recall number (16128) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official CPSC notice before acting. CPSC notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official CPSC record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
The recall includes Specialized Flux and Stix Sport and Comp model bicycle headlights and taillights sold separately as aftermarket equipment. They have rechargeable batteries with USB ports. Flux headlights: Flux headlights have a round, metal mounting system that fits both flat and drop handlebars. "Flux" is printed on the side of the black, rectangular-shaped lights and on the bottom of the pewter-colored aluminum casing. Flux taillights: Flux taillights have a pewter-colored base with a 110-lumen light on the top. They mount on 27.2 mm, 30.9 mm and Venge seat posts. The Specialized logo is printed on top of the taillights. They have a sensor to boost output in flash mode during the daytime. Stix headlights: Stix headlights are black with a 70-lumen light (Stix Sport) or a 105-lumen light (Stix Comp). They mount on handlebars between 22.2 mm and 35 mm in diameter. Stix is printed in white letters on the end of the headlight.. Units affected: About 110,000.
Why was this product recalled? ▼
The headlights and taillights can overheat, posing fire and burn hazards.
What should consumers do? ▼
Consumers should immediately stop using these recalled headlights and taillights. Return them an authorized Specialized bicycle retailer for a free repair for Flux model headlights, or a free replacement for Flux model taillights, and Stix model headlights and taillights. Consumers who bought the bicycle lights directly from Specialized should contact Specialized for return instructions.
Which agency issued this recall? ▼
This recall was issued by the CPSC on March 25, 2016. Severity: Moderate. Recall number: 16128.
How do I check if my product is affected by a recall? ▼
Check the product description and recall number (16128) against your product. Visit the official CPSC website for the most current information. You can also use our Recall Checker tool to search by product name or brand.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.
Continue exploring
Keep tracking product safety across the federal recall archive.
Recall Checker
Search the full archive by product name, brand, or recall number across every agency.
Check a product →
CPSC recalls
Every recall issued by CPSC, newest first.
Browse the feed →
RecallRadar
Live feed of the latest recalls across the FDA, CPSC and NHTSA — filter by agency and severity.
View the live feed →
Rankings
The largest recalls by units affected and the most-recalled product categories.
See the rankings →
Browse by category
Find recalls by product type to spot recurring defect patterns.
All categories →
What to do next
A step-by-step guide to refunds, repairs, and returns after a recall.
Read the guide →
Nearby Recalls in This Category
Other recalls in the same product category — useful for spotting patterns across the same defect class or manufacturer.
CPSC Moderate
LShome Photoelectric Smoke Detector Fire Alarms Recalled Due Failure to Warn During Fire Posing Serious Injury or Death…
TIANJINSHIHAOWEIXINSHENGJIDIANANZHUANGGONGCHENG, of China · 2026-02-12
CPSC Moderate
Energizer Recalls Rechargeable Lanterns Due to Overheating
· 2026-01-15
CPSC Moderate
Belkin Recalls Portable Power Banks and Wireless Charging Stands Due to Fire and Burn Hazards
Belkin International Inc., of El Segundo, California · 2025-11-13
CPSC Moderate
Tesla Recalls Powerwall 2 AC Battery Power Systems Due to Fire and Burn Hazards; Risk of Serious Injury or Death
Tesla, Inc., of Reno, Nevada · 2025-11-13
CPSC Moderate
ESR HaloLock Wireless Power Banks Recall Expanded to Include Additional Model Due to Risk of Serious Burn Injury and Fi…
Waymeet Limited, of Hong Kong · 2025-10-09
Compare this recall with LShome Photoelectric Smoke Detector Fire Alarms Recalled Du… →
Data Sources
Source: FDA, CPSC, and NHTSA federal recall databases. This recall: CPSC, reported March 25, 2016.
- Source: FDA — Food and Drug Administration, openFDA Enforcement API (food, drug, and medical device recalls)
- Source: CPSC — Consumer Product Safety Commission Recalls API (consumer product recalls and hazards)
- Source: NHTSA — National Highway Traffic Safety Administration Recalls API (vehicle safety recalls)
Recall information is sourced from official federal agency databases. Always verify recall details with the issuing agency for the most current status. This information is for research and awareness purposes only.
Every figure on PlainRecalls is rendered directly from official FDA, CPSC and NHTSA recall records — no number is typed in by an editor. Severity classes follow each agency's own taxonomy (FDA Class I/II/III; CPSC and NHTSA by hazard type), and related-recall context is computed across the full archive. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of June 2026.