Boyer Recalls Six Brands of Sodium and Potassium Hydroxide Due to Failure to Meet Child-Resistant Packaging Requirement; Injuries Reported

Recall Insight

This CPSC action (record #20092) was formally reported on March 18, 2020. It is classified under Moderate severity, with a current status of Active. The Boyer Corporation Inc., LaGrange, Ill. is listed as the recalling firm. Federal records indicate About 329,000 units are affected, a scale large enough to require multi-state distribution tracking.

The documented reason for this recall is: The products contain sodium and/or potassium hydroxide which must be in child resistant packaging as required by the Poison Prevention Packaging Act (PPPA). The packaging of the products is not child resistant, posing a… Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately store the recalled products in a safe location out of reach of children and contact Boyer for a free replacement child-resistant cap. — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC and NHTSA going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 6 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 6 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.