NHTSA recall · Reported October 15, 2020
CHEVROLET 2014: SEAT BELTS:FRONT
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV) that were previously repaired under NHTSA recall number 16V-518. The…
Chevrolet recalled General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pu….
CHEVROLET 2014: SEAT BELTS:FRONT was recalled by Chevrolet in October 15, 2020. Reason: General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV)…. Remedy: GM will notify owners, and dealers will inspect the vehicles to determine whether the new…. Verify recall #20V638000 with the NHTSA before acting.
The recall
Chevrolet issued this NHTSA recall-General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV)….
- None
- agency class
- October 15, 2020
- reported
Sourced from official NHTSA enforcement records. Verify recall #20V638000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV) that were previously repaired under NHTSA recall number 16V-518. The repair may not have been performed properly. The driver's seat belt tensioner cable may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Reason for recall
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV) that were previously repaired under NHTSA recall number 16V-518. The repair may not have been performed properly. The driver's seat belt tensioner cable may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Hazard
If the tensioner cable separates, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy, what to do
GM will notify owners, and dealers will inspect the vehicles to determine whether the new seat trim was installed and replace the trim as necessary. Dealers will also inspect and replace the pretensioner cable assembly, as necessary. Repairs will be performed free of charge. The recall began November 17, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202312100
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 20V638000 |
| Date reported | October 15, 2020 |
| Date initiated | October 15, 2020 |
| Recalling firm | Chevrolet |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
GM will notify owners, and dealers will inspect the vehicles to determine whether the new seat trim was installed and replace the…
- Check the recall number (20V638000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026