PlainRecalls
No agency classActive

NHTSA recall · Reported October 15, 2020

FORD 2020: ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the si…

Recall #
20V635000
Compiled from official public sources by the publisher.
Verify with NHTSA →
View my saved recalls

Ford recalled Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-s….

FORD 2020: ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM was recalled by Ford in October 15, 2020. Reason: Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system…. Remedy: Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are ad…. Verify recall #20V635000 with the NHTSA before acting.

The recall

Ford issued this NHTSA recall-Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system….

None
agency class
October 15, 2020
reported

Sourced from official NHTSA enforcement records. Verify recall #20V635000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.

Recall Insight

The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.

Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.

Vehicles recalls over time

Where this recall sits in its category - 7,783 vehicles recalls on record

200300400500600 20052008201120142017202020232026 222

Product description

Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.

Reason for recall

Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.

Hazard

Low tire pressure may lead to poor vehicle handling and a possible loss of vehicle control, increasing the risk of crash.

Remedy, what to do

Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.

Recall Profile

Structured summary of the NHTSA recall record
Attribute Value
Agency National Highway Traffic Safety Administration
Severity class Not classified by agency
Status Active
Recall number 20V635000
Date reported October 15, 2020
Date initiated October 15, 2020
Recalling firm Ford
Affected scope Not disclosed
Distribution United States
Official source NHTSA notice →

Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.

What to do with this recall

Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for…

  • Check the recall number (20V635000) and product description against the item you own. Search the archive
  • Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
  • Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next

This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.

Frequently Asked Questions

What product was recalled? ▼
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.. Recalled by Ford.
Why was this product recalled? ▼
Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.
What should consumers do? ▼
Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.
Which agency issued this recall? ▼
This recall was issued by the NHTSA on October 15, 2020. NHTSA does not publish a hazard classification for this recall. Recall number: 20V635000.
Where was the recalled product distributed? ▼
Distribution: United States.
How do I report an injury from a recalled product? ▼
Report injuries to the issuing agency: CPSC at SaferProducts.gov, NHTSA at nhtsa.gov/report-a-safety-problem, or FDA via MedWatch. Document the product (photos, model/serial numbers, purchase receipts) and seek medical attention. Injury reports help agencies track hazard patterns and may strengthen enforcement actions.

Nationwide recalls with similar severity or category timing

Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.

Similar severity · nearest report date

Same archive severity grade, closest by report date among other firms and states.

RAM 2014-2019: POWER TRAIN:AUTOMATIC TRAN… 2020-10-15 CHEVROLET 2014: SEAT BELTS:FRONT 2020-10-15 BUICK,CADILLAC,CHEVROLET,GMC 2020: FUEL S… 2020-10-15 FREIGHTLINER,WESTERN STAR 2018-2019: POWE… 2020-10-16

Similar Vehicles · nearest report date

Same product category, closest by report date among other firms and states (deduped against the severity set).

MERCEDES-BENZ 2020: SERVICE BRAKES, HYDRA… 2020-10-14 TOYOTA 2020: AIR BAGS 2020-10-14 FREIGHTLINER,WESTERN STAR 2020-2021: EQUI… 2020-10-14 HYUNDAI 2019-2020: ELECTRICAL SYSTEM:PROP… 2020-10-13

Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls

This recall: NHTSA, reported October 15, 2020. Severity classes follow each agency's own taxonomy; related-recall context is computed across the full archive.

Methodology · Corrections · Archive as of August 2026