NHTSA recall · Reported June 2, 2008
BMW 2008: ENGINE AND ENGINE COOLING:ENGINE
BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS SPECIFIC LOCATION WITHIN THE OIL DUCT. CONSEQUENTLY, AN ADEQUATE SUP…
Bmw recalled BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE B….
BMW 2008: ENGINE AND ENGINE COOLING:ENGINE was recalled by Bmw in June 2, 2008. Reason: BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS…. Remedy: DEALERS WILL INSTALL A SET SCREW IN THE OIL DUCT. THE RECALL BEGAN DURING AUGUST 2008. …. Verify recall #08V239000 with the NHTSA before acting.
The recall
Bmw issued this NHTSA recall-BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS….
- None
- agency class
- June 2, 2008
- reported
Sourced from official NHTSA enforcement records. Verify recall #08V239000 with the agency before acting. Full product description, hazard, remedy, and related recalls are below.
Recall Insight
The number of affected units is not disclosed in the agency filing, which is common for drug and food recalls where lot-level tracking supersedes unit counts. Distribution scope (see Distribution below) directly affects the consumer exposure window and determines whether a recall remains regional or escalates into a nationwide advisory. Consumers holding this product should act on the agency's documented remedy above rather than relying on general guidance.
Within the same product category the archive holds 6 closely related recalls, 3 from NHTSA - clustering in a narrow category often points to a systemic quality-control or supplier issue rather than a one-off defect. Always verify the recall number against the official agency record before acting.
Vehicles recalls over time
Where this recall sits in its category - 7,783 vehicles recalls on record
Product description
BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS SPECIFIC LOCATION WITHIN THE OIL DUCT. CONSEQUENTLY, AN ADEQUATE SUPPLY OF OIL MAY NOT CIRCULATE WITHIN THE ENGINE.
Reason for recall
BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS SPECIFIC LOCATION WITHIN THE OIL DUCT. CONSEQUENTLY, AN ADEQUATE SUPPLY OF OIL MAY NOT CIRCULATE WITHIN THE ENGINE.
Hazard
IT IS POSSIBLE THAT CONNECTING ROD AND CRANKSHAFT DAMAGE COULD OCCUR. IF THIS HAPPENED, THE ENGINE COULD SEIZE. IF THE MOTORCYCLE WAS IN GEAR, ENGINE SEIZING COULD RESULT IN LOCK-UP OF THE REAR TIRE, INCREASING THE RISK OF A CRASH.
Remedy, what to do
DEALERS WILL INSTALL A SET SCREW IN THE OIL DUCT. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-331-1117.
Recall Profile
| Attribute | Value |
|---|---|
| Agency | National Highway Traffic Safety Administration |
| Severity class | Not classified by agency |
| Status | Active |
| Recall number | 08V239000 |
| Date reported | June 2, 2008 |
| Date initiated | June 2, 2008 |
| Recalling firm | Bmw |
| Affected scope | Not disclosed |
| Distribution | United States |
| Official source | NHTSA notice → |
Profile values are sourced directly from the official NHTSA enforcement record. Source: National Highway Traffic Safety Administration.
What to do with this recall
DEALERS WILL INSTALL A SET SCREW IN THE OIL DUCT. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-331-1117.
- Check the recall number (08V239000) and product description against the item you own. Search the archive
- Confirm the current status and remedy on the official NHTSA notice before acting. NHTSA notice
- Follow the documented remedy (refund, replacement, repair, or disposal) rather than general advice. What to do next
This page summarizes the official NHTSA record for research and awareness; it is not legal, medical, or safety advice. Verify with the issuing agency before acting.
Frequently Asked Questions
What product was recalled? ▼
Why was this product recalled? ▼
What should consumers do? ▼
Which agency issued this recall? ▼
Where was the recalled product distributed? ▼
How do I report an injury from a recalled product? ▼
Nationwide recalls with similar severity or category timing
Vehicle and equipment notices outside this manufacturer and filing state, matched by archive severity grade and report timing.
Similar severity · nearest report date
Same archive severity grade, closest by report date among other firms and states.
Similar Vehicles · nearest report date
Same product category, closest by report date among other firms and states (deduped against the severity set).
Compare this recall with KTM North America Recalls Off-Road Motorcycles Due to Risk … → · All Vehicles recalls
Methodology · Corrections · Archive as of August 2026