American Outdoor Brands Recalls Caldwell Earmuffs with Rechargeable Lithium-Battery Packs Due to Fire and Burn Hazards

Recall Insight

This CPSC action (record #21167) was formally reported on July 21, 2021. It is classified under Moderate severity, with a current status of Active. The recalling firm is not specified in the federal record. Federal records indicate About 13,740 (In addition, about 88 were sold in Canada) units are affected, placing this recall in the million-unit bracket that typically triggers nationwide consumer alerts and retailer sweeps.

The documented reason for this recall is: The soldering within the lithium-battery pack housing can allow the wiring to detach and cause the unit to overheat, posing fire and burn hazards. Distribution information was not included in the agency filing, so consumers should assume broad potential exposure until the firm publishes point-of-sale details. The remedy documented by the agency is: Consumers should immediately remove the recalled lithium-battery pack from the earmuffs and contact American Outdoor Brands for disposal instructions in accordance with local laws and to receive free… — consumers holding this product should act on that instruction rather than relying on general guidance.

To put this record in context, PlainRecalls indexes 83,949 recalls across the FDA, CPSC, NHTSA and USDA FSIS going back to 1995. Within the same product category, the database holds 6 closely related recalls, of which 6 were also issued by CPSC. That clustering is a signal — repeated actions in a narrow category often indicate a systemic quality-control issue, a supplier-wide contamination, or a design defect that has propagated across product lines. This recall is roughly 5 years old; older recalls can remain relevant because many units enter resale, rental, and secondary-market channels where the original warning never reaches the end user. Always cross-check the recall number against the official agency page before relying on any summary.